Huagongshe화공사 화학 정보 인쇄 보고서 · 연구 참고용
Chlorine Dioxide
이산화염소 · 과산화염소 · 이산화염소(기체) · 클로린다이옥사이드 · 이산화 염소 · ClO2 · Chlorine oxide · Chlorine Dioxide solution
식별자 및 물리적 특성
| CAS No. | 10049-04-4 |
|---|---|
| 분자식 | ClO2 |
| 평균 분자량 | 67.45 g/mol |
| 단동위원소 질량 | 66.95868192 g/mol |
| SMILES | [O][Cl+][O-] |
| InChIKey | OSVXSBDYLRYLIG-UHFFFAOYSA-N |
| PubChem CID | 24870 |
| ChEMBL | CHEMBL4297725 |
| ChEBI | CHEBI:29415 |
| EC No. | 233-162-8 |
| DTXSID | DTXSID5023958 |
| 현지명 | 이산화염소(기체) |
화학 및 물리적 성질
| XLogP | 1.4 |
|---|---|
| 극성 표면적 | 18.1 |
| 수소 결합 공여자 수 | 0 |
| 수소 결합 수용자 수 | 1 |
| 회전 가능 결합 수 | 0 |
| 무거운 원자 수 | 3 |
| 형식 전하 | 0 |
| 복잡도 | 7.5 |
| 물질 분류 | Toxic Gases & Vapors -> OxidizersFlammable agents - 4th degree |
| 화장품 | Cosmetics ingredient -> Base |
| 농약 | Pesticide -> EPA IRISFungicidesActive substance -> EU Pesticides database: Not approved |
| 냄새 | ... Unpleasant odor similar to chlorine and nitric acid. |
| 식품 첨가물 | ANTIMICROBIAL AGENT, FLOUR TREATING AGENT, FUMIGANT -> FDA Substance added to food |
| 밀도 | 1.6 (Liquid at 32 °F) (NIOSH, 2024) - Denser than waterwill sink1.77 g/cu cmDensity: 1.642 at 0 °C (liq)Relative density (water = 1): 1.6 (liquid, 0 °C)1.6 (liquid at 32 °F)3.09 @ 11°C3.09g/L |
| Color/Form | Yellowish-brown gasYellow to reddish-yellow gas at room temperatureSolid chlorine dioxide is a yellowish-red crystalline massliquid is reddish-brownYellow to red gas or a red-brown liquid (below 52 degrees F) ...For more Color/Form (Complete) data for Chlorine dioxide (6 total), please visit the HSDB record page. |
| 용해도 | 0.3 % at 77 °F (NIOSH, 2024)In water, 3.01 g/L at 25 °C and 34.5 mm Hg2000 cc (gas) in 100 cc cold waterIn water, 1.823X10-2 at 298.15 KSoluble in waterSoluble in alkaline and sulfuric acid solutionsslightly soluble in H2O |
| 인화점 | NA (Gas) ? (Liquid) |
| Endocrine Disruptors | Potential endocrine disrupting compound |
| 끓는 점 | 52 °F at 760 mmHg (NIOSH, 2024)11 °C11 °C @760 [mm Hg]11°C |
| Decomposition | When heated to decomposition it emits toxic fumes of /chloride/.Decomposition by sparking begins to become hazardous at concentrations of 7-8% in air.The major chlorine dioxide /disinfectant by-products/ (DBPs) include chlorite (ClO2 -) and chlorate ions, with no direct formation of organohalogen DBPs. Unlike the other disinfectants, the major chlorine dioxide DBPs are derived from decomposition of the disinfectant as opposed to reaction with precursors. |
| 녹는점 | -59°C |
| 증기압 | 0-22900Pa at 20-25℃ |
| 물리적 상태 | 주황색-녹색 가스 |
| 색상 | orange-green |
| 용해도 | 가용성 ºC |
| 비열 | Cp(gas): 0.62 J/(g·K), at 25℃ |
| 헨리 상수 | 1.0×10-2 mol/(m3Pa) at 25℃, Burkholder et al. (2019) |
| 유전율 | 1.7(77.0℃) |
| 안정성 | 충격, 마찰, 진동 또는 급속 가열 시 폭발적으로 분해될 수 있습니다. 강력한 산화제 - 가연성 및 환원성 물질, 수은, 암모니아, 황 및 많은 유기 화합물과 격렬하게 반응합니다. |
| 화장품 원료 기능 | 항균탈취제 |
| LogP(분배 계수) | -3.22--2.9 at 20℃ |
| NIST | Chlorine dioxide(10049-04-4) |
| EPA | Chlorine dioxide (10049-04-4) |
화학적 성질
Chlorine dioxide,CI02, is a yellow-reddish gas.It is a very effective bleaching and water treatment agent. Chlorine dioxide is preparedby the reaction of chlorine and sodium chlorite. It is quite unstable and is commonly prepared immediately before use.
안전 및 규제
| GHS 분류 | DangerH270: May cause or intensify fireoxidizer [Danger Oxidizing gases]P220, P244, P260, P264, P271, P273, P280, P284, P301+P330+P331, P302+P361+P354, P304+P340, P305+P354+P338, P316, P320, P321, P363, P370+P376, P391, P403, P403+P233, P405, and P501 (click each P-code to see the statement)H301: Toxic if swallowed [Danger Acute toxicity, oral]P260, P264, P270, P273, P280, P301+P316, P301+P330+P331, P302+P361+P354, P304+P340, P305+P354+P338, P316, P321, P330, P363, P391, P405, and P501 (click each P-code to see the statement) |
|---|---|
| 규제 정보 | Chemical: Chlorine oxide, (ClO2)Hazard Traits - NeurotoxicityRespiratory ToxicityRegulation (EC) No 1331/2008Chlorine oxide (ClO2) is listed on the EPA's Chemical Data Reporting (CDR) system. Manufacturers and importers of Chlorine oxide (ClO2) are required to report information about their production and use of this chemical to the EPA under the Toxic Substances Control Act (TSCA). (40 eCFR Part 711)Status: Active Update: 15-05-2023 https://echa.europa.eu/registration-dossier/-/registered-dossier/15450Chlorine dioxide: Does not have an individual approval but may be used as a component in a product covered by a group standard. It is not approved for use as a chemical in its own right. |
| 기타 안전 정보 | IMAP assessments - Chlorine oxide, (ClO2): Human health tier I assessment |
| 운송 라벨(DOT) | Oxidizer Poison |
| 화재 위험 | Excerpt from ERG Guide 143 [Oxidizers (Unstable)]:Not combustible but enhances combustion of other substances. Many reactions may cause fire or explosion. Risk of fire and explosion. See Chemical Dangers. |
| 건강 유해성 | Excerpt from ERG Guide 143 [Oxidizers (Unstable)]: |
| 유해성 요약 | Chlorine dioxide is a yellow to reddish-yellow manufactured gas. It does not occur naturally in the environment. When added to water, chlorine dioxide forms chlorite ion, which is also a very reactive chemical. Chlorine dioxide is used as a bleaching agent at paper manufacturing plants, and in public water treatment facilities to make water safe to drink. In 2001, chlorine dioxide and chlorite were used to decontaminate a number of public buildings following the release of anthrax spores in the United States.Corrosive--can cause serious skin burns[ICSC] Rats exposed to 0.1 ppm for 5 hours/day for 45 days had no adverse effects while exposures to 2.5 ppm for 7 hours/day for 30 days caused severe lung inflammation[ACGIH] |
| 운송 번호 및 가이드(DOT) | 9191 143(hydrate, frozen) |
| FDA 요건 | Chlorine dioxide (CAS Reg. No. 10049-04-4) may be safely used in food in accordance with the following prescribed conditions: (a)(1) The additive is generated by one of the following methods: (i) Treating an aqueous solution of sodium chlorite with either chlorine gas or a mixture of sodium hypochlorite and hydrochloric acid. (ii) Treating an aqueous solution of sodium chlorate with hydrogen peroxide in the presence of sulfuric acid. (iii) Treating an aqueous solution of sodium chlorite by electrolysis. (2) The generator effluent contains at least 90 percent (by weight) of chlorine dioxide with respect to all chlorine species as determined by Method 4500-ClO2 E in the "Standard Methods for the Examination of Water and Wastewater," 20th ed., 1998, or an equivalent method. ... (b)(1) The additive may be used as an antimicrobial agent in water used in poultry processing in an amount not to exceed 3 parts per million (ppm) residual chlorine dioxide as determined by Method 4500-ClO2 E, referenced in paragraph (a)(2) of this section, or an equivalent method. (2) The additive may be used as an antimicrobial agent in water used to wash fruits and vegetables that are not raw agricultural commodities in an amount not to exceed 3 ppm residual chlorine dioxide as determined by Method 4500-ClO2 E, referenced in paragraph (a)(2) of this section, or an equivalent method. Treatment of the fruits and vegetables with chlorine dioxide shall be followed by a potable water rinse or by blanching, cooking, or canning. |
| 반응성 그룹 | Oxidizing Agents, Strong |
| EC 분류 | Symbol: O, T+, NR: 6-8-26-34-50S: (1/2)-23-26-28-36/37/39-38-45-61 |
| Special Reports | USEPA/Office of Prevention, Pesticides and Toxic SubstancesReregistration Eligibility Decision Document for Chlorine Dioxide and Sodium Chlorite EPA 738-R-06-007 (August 2006). The RED summarizes the risk assessment conclusions and outlines any risk reduction measures necessary for the pesticide to continue to be registered in the USA.[Available from, as of December 13, 2017: http://www.epa.gov/pesticides/reregistration/status.htm]HHS/ATSDRToxicological Profile for Chlorine dioxide and Chlorite (PB 2004-107332) (September 2004).[Available from, as of December 13, 2017: https://www.atsdr.cdc.gov/toxprofiles/index.asp#C]WHOEnvironmental Health Criteria 216: Disinfectants and Disinfectant By-Products (2000).[Available from, as of December 12, 2017: http://www.inchem.org/documents/ehc/ehc/ehc216.htm]Calabrese EJ et alThe Health Effects of Chlorine Dioxide as A Disinfectant in Potable Water: A Literature SurveyJ Environ Health 41 (1): 26-31 (1978). A review with 43 references on the health effects of chlorine dioxide as a disinfectant in potable water.For more Special Reports (Complete) data for Chlorine dioxide (7 total), please visit the HSDB record page. |
| FIFRA 요건 | Residues of the following chemical substances are exempted from the requirement of a tolerance when used in accordance with good manufacturing practice as ingredients in an antimicrobial pesticide formulation, provided that the substance is applied on a semi-permanent or permanent food-contact surface (other than being applied on food packaging) with adequate draining before contact with food. ... (b) The following chemical substances when used as ingredients in an antimicrobial pesticide formulation may be applied to: Dairy processing equipment, and food-processing equipment and utensils. ... Pesticide Chemical: Oxychloro species (including chlorine dioxide) generated by acidification of an aqueous solution of sodium chlorite. Limit: When ready for use, the end-use concentration is not to exceed 200 ppm of chlorine dioxide as determined by the method titled, Iodometric Method for the Determination of Available Chlorine Dioxide (50-250 ppm available chlorine dioxide)Residues of the following chemical substances are exempted from the requirement of a tolerance when used in accordance with good manufacturing practice as ingredients in an antimicrobial pesticide formulation, provided that the substance is applied on a semi-permanent or permanent food-contact surface (other than being applied on food packaging) with adequate draining before contact with food. ... (c) The following chemical substances when used as ingredients in an antimicrobial pesticide formulation may be applied to: Food-processing equipment and utensils. ... Pesticide Chemical: Oxychloro species (including chlorine dioxide) generated by acidification of an aqueous solution of sodium chlorite. Limit: When ready for use, the end-use concentration is not to exceed 200 ppm of chlorine dioxide as determined by the method titled, "Iodometric Method for the Determination of Available Chlorine Dioxide (50-250 ppm available chlorine dioxide)"Residues of the following chemical substances are exempted from the requirement of a tolerance when used in accordance with good manufacturing practice as ingredients in an antimicrobial pesticide formulation, provided that the substance is applied on a semi-permanent or permanent food-contact surface (other than being applied on food packaging) with adequate draining before contact with food. ... (c) The following chemical substances when used as ingredients in an antimicrobial pesticide formulation may be applied to: Food-processing equipment and utensils. ... Pesticide Chemical: Oxychloro species (predominantly chlorite, chlorate and chlorine dioxide in an equilibrium mixture) generated either (i) by directly metering a concentrated chlorine dioxide solution prepared just prior to use, into potable water, or (ii) by acidification of an aqueous alkaline solution of oxychloro species (predominately chlorite and chlorate) followed by dilution with potable water. Limit: When ready for use, the end-use concentration is not to exceed 200 ppm of chlorine dioxide as determined by the method titled, "Iodometric Method for the Determination of Available Chlorine Dioxide (50-250 ppm available chlorine dioxide)"The Agency has completed its assessment of the dietary, occupational, drinking water, and ecological risks associated with the use of pesticide products containing the active ingredient chlorine dioxide and sodium chlorite. Based on a review of these data and on public comments on the Agency's assessments for the active ingredient chlorine dioxide and sodium chlorite, the Agency has sufficient information on the human health and ecological effects of chlorine dioxide and sodium chlorite to make decisions as part of the tolerance reassessment process under FFDCA and reregistration process under FIFRA, as amended by FQPA. The Agency has determined that all chlorine dioxide and sodium chlorite pesticide-containing products are eligible for reregistration provided that: (i) current data gaps and confirmatory data needs are addressed(ii) the risk mitigation measures outlined in this document are adoptedand (iii) label amendments are made to reflect these measures. ... Based on its evaluation of chlorine dioxide and sodium chlorite, the Agency has determined that chlorine dioxide and sodium chlorite products, unless labeled and used as specified in this document, would present risks inconsistent with FIFRA. Accordingly, should a registrant fail to implement any of the risk mitigation measures identified in this document, the Agency may take regulatory action to address the risk concerns from the use of chlorine dioxide and sodium chlorite. If all changes outlined in this document are incorporated into the product labels, then all current risks for chlorine dioxide and sodium chlorite will be substantially mitigated for the purposes of this determination.As the federal pesticide law FIFRA directs, EPA is conducting a comprehensive review of older pesticides to consider their health and environmental effects and make decisions about their continued use. Under this pesticide reregistration program, EPA examines newer health and safety data for pesticide active ingredients initially registered before November 1, 1984, and determines whether the use of the pesticide does not pose unreasonable risk in accordance to newer safety standards, such as those described in the Food Quality Protection Act of 1996. Pesticides for which EPA had not issued Registration Standards prior to the effective date of FIFRA '88 were divided into three lists based upon their potential for human exposure and other factors, with List B containing pesticides of greater concern than those on List C, and with List C containing pesticides of greater concern than those on List D. Chlorine dioxide is found on List D. Case No: 4023Pesticide type: insecticide, fungicide, herbicide, antimicrobialCase Status: RED Approved 09/94OPP has made a decision that some/all uses of the pesticide are eligible for reregistration, as reflected in a Reregistration Eligibility Decision (RED) document.Active ingredient (AI): chlorine dioxideData Call-in (DCI) Date(s): 09/07/93AI Status: The producers of the pesticide have made commitments to conduct the studies and pay the fees required for reregistration, and are meeting those commitments in a timely manner. |
| 소화 | Excerpt from ERG Guide 143 [Oxidizers (Unstable)]:In case of fire in the surroundings, use appropriate extinguishing media. In case of fire: keep drums, etc., cool by spraying with water. Combat fire from a sheltered position. |
| 응급 조치 | Fresh air, rest. Half-upright position. Refer for medical attention.First rinse with plenty of water for at least 15 minutes, then remove contaminated clothes and rinse again. Refer for medical attention .First rinse with plenty of water for several minutes (remove contact lenses if easily possible), then refer for medical attention. |
| 응급 처치 | Excerpt from NIOSH Pocket Guide for Chlorine dioxide:(General first aid procedures) |
| 안전 보관 | Fireproof if in building. Separated from combustible substances and reducing agents. Cool. Keep in the dark. Ventilation along the floor. |
| Firefighting Hazards | A powerful oxidizer, this chemical will increase the intensity of a fire, and can cause fire upon contact with combustibles. ... Vapors are heavier than air and will collect in low areas. Containers may explode in fire. Storage containers and parts of containers may rocket great distances, in many directions. |
| 노출 관리 및 개인 보호 | TIH (Toxic Inhalation Hazard) - Term used to describe gases and volatile liquids that are toxic when inhaled. Some are TIH materials themselves, e.g., chlorine, and some release TIH gases when spilled in water, e.g., chlorosilanes. [ERG 2016].0.1 [ppm] |
| 소화 절차 | If material on fire or involved in fire: Use water in flooding quantities as fog. Cool all affected containers with flooding quantities of water. Extinguish fire using agent suitable for type of surrounding fire. (Material itself does not burn or burns with difficulty.) /Chlorine dioxide hydrate, frozen/If fire becomes uncontrollable, consider evacuation of one-third mile radius. /Chlorine dioxide hydrate, frozen/Firefighting gear (including SCBA) may not provide adequate protection. If exposure occurs, remove and isolate gear immediately and thoroughly decontaminate personnel. ... Use water only. Do not use dry chemical or carbon dioxide extinguishers. Use water with caution as chlorine dioxide reacts with water, forming hydrogen chloride gas. ... If material or contaminated runoff enters waterways, notify downstream users of potentially contaminated waters. Notify local health and fire officials and pollution control agencies. From a secure, explosion-proof location, use water spray to cool exposed containers. If cooling streams are ineffective (venting sound increases in volume and pitch, tank discolors, or shows any signs of deforming), withdraw immediately to a secure position. The only respirators recommended for firefighting are self-contained breathing apparatuses that have full face-pieces and are operated in a pressure-demand or other positive-pressure mode.Small fire: Use water. Do not use dry chemicals or foams. CO2 or Halon may provide limited control. Large fire: Flood fire area with water from a distance. Do not move cargo or vehicle if cargo has been exposed to heat. Move containers from fire area if you can do it without risk. Do not get water inside containers: a violent reaction may occur. Fire involving tanks or car/trailer loads: Cool containers with flooding quantities of water until well after fire is out. Dike fire-control water for later disposal. ALWAYS stay away from tanks engulfed in fire. For massive fire, use unmanned hose holders or monitor nozzlesif this is impossible, withdraw from area and let fire burn. |
| 보관 조건 | Store separately from all other flammable materials. Prior to working with chlorine dioxide you should be trained on its proper handling and storage. This chemical is a powerful oxidizer, and is shock-, light- and heat sensitive. It is violently explosive in air at concentrations over 10%. Keep frozen when not in use. Store in tightly closed containers in a cool, dark, well-ventilated area at temperatures well below 130 °C. Gas explosions may occur above 130 °C. Use only nonsparking tools and equipment, especially when opening and closing containers of this chemical. Sources of ignition, such as smoking and open flames, are prohibited where this chemical is used, handled, or stored in a manner that could create a potential fire or explosion hazard. Use explosion-proof electrical equipment and fittings in storage area. |
| 정리 방법 | Evacuate and restrict persons not wearing protective equipment from area of spill or leak until cleanup is complete. Remove all ignition sources. Ventilate area of leak or spill. If the gas is leaked, stop the flow of gas if it can be done safely. If the source of the leak is a cylinder and the leak cannot be stopped in place, remove the leaking cylinder to a safe place in the open air and repair the leak or alow the cylinder to empty. If the leak can be stopped in place, bubble chlorine dioxide through a solution made up of reducing agent sodium bisulfide and sodium bicarbonate with a trap in the line. For liquid spills, allow chlorine dioxide to evaporate with all available ventilation. Keep chlorine dioxide out of a confined space, such as a sewer, because of the possibility of an explosion, unless the sewer is designed to prevent the buildup of explosive concentrations. It may be necessary to contain and dispose of this chemical as a hazardous waste. If material or contaminated runoff enters waterways, notify downstream users of potentially contaminated waters.Chlorine dioxide, hydrate, frozen, when spilled in water. Small spills (from a small package or a small leak from a large package): First: Isolate in all directions 100 ft/30 m. Then: Protect persons downwind: Day 0.1 mi/0.2 km, Night 0.1 mi/0.2 km. Large spills (from a large package or many small packages): First: Isolate in all directions 100 ft/30 m. Then: Protect persons downwind: Day 0.2 mi/0.3 km, Night 0.4 mi/0.6 km. /Chlorine dioxide, hydrate, frozen/1) Remove all ignition sources. 2) Ventilate area of spill or leak. 3) If in gaseous form, stop flow of gas. If source of leak is a cylinder and leak cannot be stopped in place, remove leaking cylinder to safe place in open air, and repair leak or allow cylinder to empty. 4) If in liquid form, evacuate persons not wearing protective equipment. ... Allow ... to evaporate while providing all available ventilation. |
| 비화재 누출 대응 | Excerpt from ERG Guide 143 [Oxidizers (Unstable)]: |
| 처리 방법 | SRP: Recycle any unused portion of the material for its approved use or return it to the manufacturer or supplier. Ultimate disposal of the chemical must consider: the material's impact on air qualitypotential migration in air, soil or watereffects on animal, aquatic and plant lifeand conformance with environmental and public health regulations. If it is possible or reasonable use an alternative chemical product with less inherent propensity for occupational harm/injury/toxicity or environmental contamination.SRP: Wastewater from contaminant suppression, cleaning of protective clothing/equipment, or contaminated sites should be contained and evaluated for subject chemical or decomposition product concentrations. Concentrations shall be lower than applicable environmental discharge or disposal criteria. Alternatively, pretreatment and/or discharge to a permitted wastewater treatment facility is acceptable only after review by the governing authority and assurance that "pass through" violations will not occur. Due consideration shall be given to remediation worker exposure (inhalation, dermal and ingestion) as well as fate during treatment, transfer and disposal. If it is not practicable to manage the chemical in this fashion, it must be evaluated in accordance with EPA 40 CFR Part 261, specifically Subpart B, in order to determine the appropriate local, state and federal requirements for disposal.Use large volume of concentrated solution of ferrous salt or bisulfite solution as reducing agent. Then neutralize and flush to sewer with abundant water. |
| 누출 처리 | Evacuate danger area! Consult an expert! Personal protection: complete protective clothing including self-contained breathing apparatus. Ventilation. Remove gas with fine water spray. |
| 독성학 정보 | CDC-ATSDR Toxicological Profile |
| 표적 장기 | Developmental (effects while organs are developing), Gastrointestinal (Stomach and Intestines, part of the digestive system), Respiratory (From the Nose to the Lungs)CardiovascularEyes, respiratory system |
| 생태독성 수치 | LC50Species: Pimephales promelas (Fathead minnow) juvenileConditions: flow throughConcentration: 0.02 mg/L for 96 hrSpecies: Pimephales promelas (Fathead minnow) adult- 1 yr oldConcentration: 0.17 mg/L for 96 hrSpecies: Lepomis macrochirus (Bluegill) young of the yearConcentration: 0.15 mg/L for 96 hrSpecies: Carcinus maenas (Green or Europeon shore crab)Conditions: renewalConcentration: 500 mg/L for 48 hr /technical product/For more Ecotoxicity Values (Complete) data for Chlorine dioxide (16 total), please visit the HSDB record page. |
| 환경 거동 | Hydrogen peroxide (H2O2), chlorite, chlorate, Cl2O3, oxygen (O2), and chlorine have all been reported as intermediates or products /of chlorine dioxide breakdown/. Presumably chlorine dioxide will not persist in open basins or reservoirs, although it can remain for days in clean distribution systems.It is generally accepted that the predominant reaction product of chlorine dioxide in water treatment is chlorite and that chlorate and other ions are produced in minor amounts ... an approximately 50% conversion of chlorine dioxide to chlorite was reported ... /in/ water containing natural humic acids.Chlorine dioxide does not cause formation of trihalomethanes, does not react with ammonia, and does not cause formation of chloramines. It can ... disproportionate to chlorate and chlorite ... by raising pH to 11 or 12 ... this is not believed to be an important reaction in water undergoing treatment./Products formed during oxidative treatment of water/: both oxygenated and chlorinated products may be formed, the latter being found most prominently in connection with reactions of phenolic substances. Other products that might affect health are quinones and 1,2-epoxy compounds. |
| 유해 작용 | Dermatotoxin - Skin burns. |
| 노출 경로 | The substance can be absorbed into the body by inhalation.inhalation, ingestion (liquid), skin and/or eye contact |
| 독성 요약 | IDENTIFICATION AND USE: Chlorine dioxide is a yellowish-brown gas with unpleasant odor similar to chlorine and nitric acid. Its uses include bleaching cellulose, paper-pulp, flour, leather, fats and oils, textiles, and beeswax. It is also used for purification of water, taste and odor control of water, cleaning and detanning leather, in the manufacture of chloride salts, and as an oxidizing agent, bactericide, antiseptic and deodorizer. Chlorine dioxide was found to be highly effective against various microorganisms tested at very low concentrations in a minimum contact time of 30 to 60 seconds. HUMAN STUDIES: Potential symptoms of overexposure are irritation of eyes, nose, and throat, as well as coughing, wheezing, bronchitis, and pulmonary edema. Workers industrially exposed to low concentrations of the gas in air have been noted occasionally to suffer from irritation of the eyes and to see haloes about lights, but these effects have been minor compared to respiratory irritation. Bronchoscopy and biopsy revealed slight chronic bronchitis in 7 of 12 workers. Only two workers who had been exposed just prior to examination showed physical signs of respiratory effects. Workers acutely exposed to chlorine dioxide developed both reactive airways dysfunction syndrome (RADS), a form of occupational asthma, and an upper airways reactive disorder that was called reactive upper airways disfunction syndrome (RUDS). A positive association was found between exposure of the mother to chlorine dioxide-treated water during pregnancy and prematurity of the newborn. Children born of mothers who drank disinfected water treated with either chlorine dioxide or hypochlorite were noted to have an increased incidence of small cranial circumference, small body length, and neonatal jaundice. Chlorine dioxide was found to be weakly genotoxic in human leukocytes. ANIMAL STUDIES: Chlorine dioxide is very toxic by inhalation in rats. Clinical signs of toxicity included respiratory distress. Macroscopically, pulmonary edema and emphysema were seen in all groups of chlorine dioxide-exposed animals, with the incidence increasing in a dose-related manner. Chlorine dioxide is toxic when administered in solution by the oral route to rats. Two males and two females receiving 80 mg chlorine dioxide/kg body weight died, and a further two males at 40 mg/kg body weight also died within 48 hr of administration. There were no deaths at 20 mg/kg body weight. A developmental study in rats did not demonstrate any impairment of reproductive function, and there were no signs of developmental effects among rats receiving up to 10 mg aqueous chlorine dioxide/kg body weight per day. A negative result was obtained for micronucleus formation, and there were no increases in the number of structural or numerical chromosome aberrations in mice treated with chlorine dioxide. However, chlorine dioxide increased water genotoxicity in assays with E. coli and with S. cerevisiae. In Chinese hamster ovary cells at 2.5-15 ug/mL, there was a marked dose-related, statistically significant increase in the number of metaphases with chromosome aberrations. In the presence of metabolic activation, cell toxicity and an absence of mitotic cells were observed at 75 ug/mL. An increase in the number of metaphases with chromosome aberrations was noted at 50 ug/mL. ECOTOXICITY STUDIES: Developmental abnormalities in the sea urchin were evident at exposure to the chlorine dioxide concentration 250 mg/L. Compared with the control, pre-hatch malformations were 6% higherretarded development, 2%post-hatch malformations, 20%skeletal malformations, 21%and gut malformations, 11%. Survival of larval kelp bass was not significantly affected by chlorine dioxide. In Fathead minnows (Pimephales promelas) chlorine dioxide exposure produced dose-dependent gill pathology including epithelial lifting, hypertrophy, hyperplasia, lamellar fusion, and necrosis. Complete recovery, even in fish with severe hypertrophy and lamellar fusion, was achieved within 4 days. Chlorine dioxide concentrations ranging from 0.1 to 0.5 mg/L induced micronuclei in Vicia faba at acid pH, while 1-2 mg/L chlorine dioxide gave positive responses at neutral pH. Chlorine dioxide produced positive responses in the Tradescantia micronucleus test. |
| 생태독성 발췌 | /AQUATIC SPECIES/ Antifouling biocides are commonly used in coastal electric power stations to prevent biofouling in their condenser cooling systems. However, the environmental impact of the chemical biocides is less understood than the thermal stress effects caused by the condenser effluents. In this study, Chaetoceros lorenzianus, a representative marine diatom, was used to analyze the toxicity of two antifouling biocides, chlorine and chlorine dioxide. The diatom cells were subjected to a range of concentrations of the biocides (from 0.05 to 2 mg/L, as total residual oxidants, TRO) for contact time of 30min. They were analyzed for viability, genotoxicity, chlorophyll a and cell density endpoints. The cells were affected at all concentrations of the biocides (0.05-2 mg/L), showing dose-dependent decrease in viability and increase in DNA damage. The treated cells were later incubated in filtered seawater devoid of biocide to check for recovery. The cells were able to recover in terms of overall viability and DNA damage, when they had been initially treated with low concentrations of the biocides (0.5 mg/L of Cl2 or 0.2 mg/L of ClO2). Chlorophyll a analysis showed irreparable damage at all concentrations, while cell density showed increasing trend of reduction, if treated above 0.5 mg/L of Cl2 and 0.2 mg/L of ClO2. The data indicated that in C. lorenzianus, cumulative toxic effects and recovery potential of ClO2 up to 0.2 mg/L were comparable with those of Cl2, up to 0.5 mg/L concentration in terms of the studied endpoints. The results indicate that at the biocide levels currently being used at power stations, recovery of the organism is feasible upon return to ambient environment. Similar studies should be carried out on other planktonic and benthic organisms, which will be helpful in the formulation of future guidelines for discharge of upcoming antifouling biocides such as chlorine dioxide./AQUATIC SPECIES/ Environmental effect evaluation of disinfection of combined sewer overflow events with alternative chemical disinfectants requires that the environmental toxicity of the disinfectants and the main by-products of their use are known. Many disinfectants degrade quickly in water which should be included in the evaluation of both their toxicity as determined in standardized tests and their possible negative effect in the water environment. Here we evaluated according to the standardized ISO 8692 test the toxicity towards the green microalgae, Pseudokirchneriella subcapitata, of three disinfectants: performic acid (PFA), peracetic acid (PAA) and chlorine dioxide (ClO2) as well as two by-products of their use: hydrogen peroxide (H2O2) and chlorite. All of the five chemicals investigated showed clear toxicity to the algae with well-defined dose response curves. The EC50 values ranged from 0.16 to 2.9 mg/L based on nominal concentrations leading to the labeling of the chemicals as either toxic or very toxic. The five investigated chemicals decreased in toxicity in the order chlorine dioxide, performic acid, peracetic acid, chlorite and hydrogen peroxide. The stability of the chemicals increased in the same order as the toxicity decrease. This indicates that even though ClO2 has the highest environmental hazard potential, it may still be suitable as an alternative disinfectant due to its rapid degradation in water./AQUATIC SPECIES/ Whether the implementation of additional treatments for the removal of estrogens from wastewater treatment works (WwTWs) effluents will eliminate their feminizing effects in exposed wildlife has yet to be established, and this information is crucial for future decisions on investment into WwTWs. Here, granular activated carbon (GAC), ozone (O(3)), and chlorine dioxide (ClO(2)) were investigated for their effectiveness in reducing steroidal estrogen levels in a WwTW effluent and assessments made on the associated estrogenic and reproductive responses in fathead minnows (Pimephales promelas) exposed for 21 days. All treatments reduced the estrogenicity of the standard-treated (STD) effluent, but with different efficaciesranging between 70-100% for total estrogenicity and 53-100% for individual steroid estrogens. In fish exposed to the GAC- and ClO(2)- (but not O(3)-) treated effluents, there was no induction of plasma vitellogenin (VTG) or reduction in the weight of the fatpad, a secondary sex character in males, as occurred for fish exposed to STD effluent. This finding suggests likely benefits of employing these treatment processes for the reproductive health in wild fish populations living in rivers receiving WwTW discharges. Exposure of pair-breeding minnows to the GAC-treated effluent, however, resulted in a similar inhibition of egg production to that occurring for exposure to the STD effluent (34-40%). These data, together with a lack of effect on egg production of the estrogen, ethinylestradiol (10 ng/L), alone, suggest that chemical/physical properties of the effluents rather than their estrogenicity were responsible for the reproductive effect and that these factor(s) were not remediated for through GAC treatment. Collectively, our findings illustrate the importance of assessing integrative biological responses, rather than biomarkers alone, in the assessment and improvement of WwTW technologies for the protection of wild fish populations./AQUATIC SPECIES/ Epidemiological evidence suggests a link between consumption of chlorinated drinking water and various cancers. Chlorination of water rich in organic chemicals produces carcinogenic organochlorine by-products (OBPs) such as trihalomethanes and haloacetic acids. Since the discovery of the first OBP in the 1970s, there have been several investigations designed to determine the biological effects of single chemicals or small artificial OBP combinations. However, there is still insufficient information regarding the general biological response to these compounds, and further studies are still needed to evaluate their potential genotoxic effects. In the current study, we evaluated the effect of three drinking water disinfectants on the activity of cytochrome P450 (CYP)-linked metabolizing enzymes and on the generation of oxidative stress in the livers of male and female Cyprinus carpio fish (carp). The fish were exposed in situ for up 20 days to surface water obtained from the Trasmene lake in Italy. The water was treated with 1-2 mg/L of either sodium hypochlorite (NaClO) or chlorine dioxide (ClO2) as traditional disinfectants or with a relatively new disinfectant product, peracetic acid (PAA). Micronucleus (MN) frequencies in circulating erythrocytes from the fish were also analyzed as a biomarker of genotoxic effect. In the CYP-linked enzyme assays, a significant induction (up to a 57-fold increase in the deethylation of ethoxyresorufin with PAA treatment) and a notable inactivation (up to almost a 90% loss in hydroxylation of p-nitrophenol with all disinfectants, and of testosterone 2beta-hydroxylation with NaClO) was observed in subcellular liver preparations from exposed fish. Using the electron paramagnetic resonance (EPR) spectroscopy radical-probe technique, we also observed that CYP-modulation was associated with the production of reactive oxygen species (ROS). In addition, we found a significant increase in MN frequency in circulating erythrocytes after 10 days of exposure of fish to water treated with ClO2, while a non-significant six-fold increase in MN frequency was observed with NaClO, but not with PAA. Our data suggest that the use of ClO2 and NaClO to disinfect drinking water could generate harmful OBP mixtures that are able to perturb CYP-mediated reactions, generate oxidative stress and induce genetic damage. These data may provide a mechanistic explanation for epidemiological studies linking consumption of chlorinated drinking water to increased risk of urinary, gastrointestinal and bladder cancers.For more Ecotoxicity Excerpts (Complete) data for Chlorine dioxide (14 total), please visit the HSDB record page. |
| Signs and Symptoms | Cough. Headache. Laboured breathing. Nausea. Shortness of breath. Sore throat. Symptoms may be delayed.Redness. Pain.irritation eyes, nose, throatcough, wheezing, bronchitis, pulmonary edemachronic bronchitis |
| ICSC Environmental Data | This substance may be hazardous to the environment. Special attention should be given to aquatic organisms. |
| EPA IRIS Information | Chlorine dioxideCardiovascular3 x 10 ^-2 mg/kg-day2 x 10 ^-4 mg/m^3 |
| Human Toxicity Excerpts | /HUMAN EXPOSURE STUDIES/ An assessment of the safety of chronically administered chlorine water disinfectants in man was conducted in 3 phases. Phase I, a rising dose tolerance investigation, examined the effects of single dose incr concn admin of disinfectants to normal healthy adult male volunteers. Phase II considered the impact on normal subjects of 12 wk daily ingestion of the disinfectants at a concn of 5 mg/L. In phase III, chlorite, at a concn of 5 mg/L, was administered daily to glucose 6-phosphate dehydrogenase (G-6-PD)-deficient subjects. The study affirmed the relative safety and tolerance of normal healthy adult males and normal healthy adult male G-6-PD-deficient individuals to daily 12 wk ingestion of 500 mL of chlorine disinfectants at a concentration of 5 mg/L. /Disinfection byproducts//HUMAN EXPOSURE STUDIES/ In a series of extensive human volunteer studies on water disinfectants, groups of 10 males received aqueous chlorine dioxide in drinking-water by a range of different protocols (a sequence of rising concentrations of up to around 0.34 mg/kg body weight over a 16-day period, approximately 0.035 mg/kg body weight on every third day for 12 weeks, or approximately 3.6 x 10-5 mg aqueous chlorine dioxide/kg body weight per day daily for 12 weeks). Observations included physical examination (blood pressure, respiration rate, pulse, oral temperature, and electrocardiography), extensive blood biochemistry, hematology, and urinalysis, and the subjective recording of taste. There were no significant adverse effects recorded for any of the parameters measured./SIGNS AND SYMPTOMS/ Potential symptoms of overexposure are irritation of eyes, nose, and throatcoughing, wheezing, bronchitis, pulmonary edemachronic bronchitis./SIGNS AND SYMPTOMS/ ... A 5 ppm concentration of chlorine dioxide was definitely irritating and ... 19 ppm of the gas inside a bleach tank was more than sufficient to cause the death of one worker (time of exposure not specified) ... . Based on these findings, /investigators/ suggested in 1950 a maximal acceptable concentration of 1 ppm.For more Human Toxicity Excerpts (Complete) data for Chlorine dioxide (26 total), please visit the HSDB record page. |
| DHS Chemicals of Interest (COI) | Chlorine dioxide11000A Commercial GradeA Placarded AmountToxic chemical that can be released at a facility. |
| 주 식수 지침 | (ME) MAINE 210 ug/L |
| Federal Drinking Water Standards | EPA 800 ug/L |
| 연방 식수 지침 | EPA 800 ug/L |
| 직업 노출 등급(OEB) | C |
| 직업 노출 한계(OEL) | TWA: 0.1 ppm (0.3 mg/m3), STEL: 0.3 ppm (0.9 mg/m3) |
| 즉시 생명 위험 농도 | 5 ppm |
| TSCA 등재 상태 | TSCA listed |
| 운송 번호(UN) | UN 9191 |
| 위험 문구(R) | 6-8-26-34-50 |
| 위험 표시 | O,T+,N |
| 안전 문구(S) | 23-26-28-36/37/39-38-45-61 |
| 기존화학 물질 | KE-05487 |
| 유해 물질 데이터 | 10049-04-4(Hazardous Substances Data) |
| 함량 및 규제정보 | 물질구분: 유독물질혼합물(제품)함량정보: 이산화 염소 및 1% 이상 함유한 혼합물 |
| 유해화학물질 필터링 | 2013-1-669 |
| 사고대비 물질 필터링 | 55 |
용도
용도
Chlorine Dioxide is a gas used in bleaching and aging flour. it acts on the flour almost instantly, resulting in improved color and dough properties. because usage levels are low, the bleaching action is limited.
제조 및 합성 방법
제조 방법
Chlorine dioxide is prepared by passing nitrogen dioxide through sodium chlorate packed in a column: NaClO3 + NO2 → NaNO3 + ClO2 Also, it may be prepared by the reaction of chlorine with sodium chlorite: 2NaClO2 + Cl2 → 2ClO2 + 2NaClAlternatively, it may be obtained by the treatment of sodium chlorate or potassium chlorate with sulfur dioxide and sulfuric acid: 2NaClO3 + SO2 + H2SO4 → 2ClO2 + 2 NaHSO4.
생산 방법
Chlorine dioxide is manufactured from the oxidation of chlorite or the reduction of chlorate. The latter method is used for large-volume production and is carried out in strongly acidic solution using reducing agents such as NaCl, HCl, sulfur dioxide, and methanol.