Ammoniak, wssrige Lsung

Excerpt from ERG Guide 154 [Substances - Toxic and/or Corrosive (Non-Combustible)]:

In case of fire in the surroundings, use appropriate extinguishing media. In case of fire: keep drums, etc., cool by spraying with water.

Fresh air, rest. Artificial respiration may be needed. Refer for medical attention.

Remove contaminated clothes. Rinse skin with plenty of water or shower for at least 15 minutes. Refer immediately for medical attention .

Rinse with plenty of water for several minutes (remove contact lenses if easily possible). Refer immediately for medical attention.

Rinse mouth. Do NOT induce vomiting. Give one or two glasses of water to drink. Refer for medical attention .

· CALL 911. Then call emergency response telephone number on shipping paper. If shipping paper not available or no answer, refer to appropriate telephone number listed on the inside back cover.

· Do not touch or walk through spilled material.

· CALL 911. Then call emergency response telephone number on shipping paper. If shipping paper not available or no answer, refer to appropriate telephone number listed on the inside back cover.

· ELIMINATE all ignition sources (no smoking, flares, sparks or flames) from immediate area.

· CALL 911. Then call emergency response telephone number on shipping paper. If shipping paper not available or no answer, refer to appropriate telephone number listed on the inside back cover.

· ELIMINATE all ignition sources (no smoking, flares, sparks or flames) from immediate area.

Excerpt from ERG Guide 154 [Substances - Toxic and/or Corrosive (Non-Combustible)]:

General First Aid:

General First Aid:

General First Aid:

General First Aid:

· Wear positive pressure self-contained breathing apparatus (SCBA).

· Wear positive pressure self-contained breathing apparatus (SCBA).

· Wear positive pressure self-contained breathing apparatus (SCBA).

· Wear positive pressure self-contained breathing apparatus (SCBA).

SRP: At the time of review, criteria for land treatment or burial (sanitary landfill) disposal practices are subject to significant revision. Prior to implementing land disposal of waste residue (including waste sludge), consult with environmental regulatory agencies for guidance on acceptable disposal practices.

Neutralization: Put into large vessel containing water. Neutralize with hydrochloric acid. ... Recommendable methods: Landfill, ... chemical treatment. Not recommendable method: Thermal destruction. Peer-review: Small amounts only: Landfill, great dilution before discharge to sewer. Large amounts of ammonia in landfill leachate may make disposal of leachate difficult. (Peer-review conclusions of an IRPTC expert consultation (May 1985))

Evacuate danger area! Consult an expert! Personal protection: complete protective clothing including self-contained breathing apparatus. Ventilation. Do NOT let this chemical enter the environment. Cautiously neutralize spilled liquid with dilute acid such as dilute sulfuric acid. Wash away remainder with plenty of water.

SRP: The scientific literature for the use of contact lenses in industry is conflicting. The benefit or detrimental effects of wearing contact lenses depend not only upon the substance, but also on factors including the form of the substance, characteristics and duration of the exposure, the uses of other eye protection equipment, and the hygiene of the lenses. However, there may be individual substances whose irritating or corrosive properties are such that the wearing of contact lenses would be harmful to the eye. In those specific cases, contact lenses should not be worn. In any event, the usual eye protection equipment should be worn even when contact lenses are in place.

Use care in handling strong ammonia solution because of caustic nature of solution & irritating properties of its vapor. Cool container well before opening, & cover closure with a cloth or similar material while opening.

... GREATEST HAZARD OF WORKING WITH ALKALINE MATERIALS IS FROM SPLASH OR SPLATTER OF PARTICLES OR SOLN OF STRONGER ALKALIES ENTERING EYES OF WORKMEN. THIS CAN BE PREVENTED BY USE OF EYE PROTECTION THAT IS EFFECTIVE AT ALL ANGLES. PROPER PROVISIONS SHOULD ... BE AVAIL FOR IMMEDIATE & PROLONGED WASHING WITH WATER SHOULD ... EYE CONTAMINATION OCCUR.

SRP: Contaminated protective clothing should be segregated in such a manner so that there is no direct personal contact by personnel who handle, dispose, or clean the clothing. Quality assurance to ascertain the completeness of the cleaning procedures should be implemented before the decontaminated protective clothing is returned for reuse by the workers.

Excerpt from ERG Guide 154 [Substances - Toxic and/or Corrosive (Non-Combustible)]:

Immediate precautionary measure

Immediate precautionary measure

Immediate precautionary measure

Immediate precautionary measure

Small spill:

LC50 Lepomis macrochirus (bluegill) 0.024-0.093 mg/l/48 hr. /Conditions of bioassay not specified/

LC50 Ictalurus punctatus (channel catfish) 0.974 mg/liter/one week pH= 7.7 Temp= 21.1 degrees C. /Conditions of bioassay not specified/

LC50 Ictalurus punctatus (channel catfish) 1.27 mg/liter/one week pH= 7.8 Temp= 21.7 degrees C. /Conditions of bioassay not specified/

LC50 Ictalurus punctatus (channel catfish) 1.41 mg/liter/one week pH= 7.8 Temp= 22.8 degrees C. /Conditions of bioassay not specified/

For more Ecotoxicity Values (Complete) data for AMMONIUM HYDROXIDE (21 total), please visit the HSDB record page.

The CIR Expert Panel concluded that Ammonia and Ammonium Hydroxide are safe as used in hair dyes and colors and safe in cosmetics applied directly to the skin in the present practices of use and concentration described in the safety assessment when formulated to be non-irritating.

Safe for use in cosmetics, with qualifications

Cough. Sore throat. Burning sensation. Laboured breathing. Shortness of breath.

Redness. Pain. Blisters. Serious skin burns.

Redness. Pain. Blurred vision. Severe burns.

Sore throat. Vomiting. Abdominal pain.

The following medical procedures should be made available to each employee who is exposed to ammonia at potentially hazardous levels: (1) A complete medical history and physical examination: the purpose is to detect existing conditions that might place the exposed employee at increased risk, and to establish a baseline for future health monitoring. Examination of the eyes and respiratory tract should be stressed. The skin should be examined for evidence of chronic disorders; (2) 14" x 17" chest roentgenogram: Ammonia causes human lung damage. Surveillance of the lung is indicated; (3) FVC and FEV (1 sec): Ammonia is a respiratory irritant. Persons with impaired pulmonary function may be at increased risk from exposure. Periodic surveillance is indicated. Medical examinations should be repeated on an annual basis, except that an X-ray is necessary only when indicated by the results of pulmonary function testing, or by signs and symptoms of respiratory disease. /Ammonia/

... IN CASE IN WHICH 1 DROP OF AMMONIUM HYDROXIDE SOLN OF APPROX 9% CONCN WAS ACCIDENTALLY APPLIED TO PATIENTS EYE, & IRRIGATION WITH WATER ... STARTED WITHIN 10 SEC BECAUSE OF IMMEDIATE SEVERE PAIN & BLEPHAROSPASM, PH OF CONJUNCTIVA & CORNEA ... WITHIN 3 MIN ... RETURNED TO NORMAL, YET MOST OF CORNEAL EPITHELIUM WAS ALREADY LOST.

IN SEVERE INJURIES, WHERE CONCN AMMONIUM HYDROXIDE SOLN ... HAS SPLASHED INTO EYE, OR FOLLOWING CONTACT WITH DIL SOLN, BUT WITH DELAY IN 1ST AID IRRIGATION, THROMBOSIS OF CONJUNCTIVAL & EPISCLERAL VESSELS, EVIDENT ON BIOMICROSCOPIC EXAM, MAY GIVE EARLY EYE UNNATURAL PALLOR & COOKED APPEARANCE.

... A CASE OF SEVERE CORNEAL & CONJUNCTIVAL ULCER WHICH DEVELOPED 10 DAYS AFTER AMMONIA WATER SPLASHED IN EYE /IS REPORTED/.

AMMONIUM HYDROXIDE DIFFERS FROM OTHER ALKALIS IN ITS VOLATILITY; VAPOR (NH3) EVEN IN LOW CONCN IS EXTREMELY IRRITATING TO SKIN, EYES, & RESP PASSAGES. ... INGESTION OF AMMONIA SOLN PRODUCES EFFECTS SIMILAR TO OTHER CORROSIVE ALKALIS, NOTABLY CORROSIVE ESOPHAGITIS & GASTRITIS.

For more Human Toxicity Excerpts (Complete) data for AMMONIUM HYDROXIDE (12 total), please visit the HSDB record page.

... APPLICATION OF 28.5% AMMONIUM HYDROXIDE TO /RABBIT/ EYES FOR 2-20 SEC (BEFORE IRRIGATION WITH WATER) CAUSES INJURY RANGING FROM FAINT PERMANENT CORNEAL NEBULA TO PROFOUND CORNEAL OPACIFICATION & VASCULARIZATION PROPORTIONAL TO LENGTH OF EXPOSURE ... .

SOLN AT PH 9-11.5 APPLIED CONTINUOUSLY TO GINGIVAL CREVICE OF MONKEYS CAUSED ULCERATIVE LESIONS SIMILAR TO THOSE SEEN IN ACUTE NECROTIZING ULCERATIVE GINGIVITIS, BUT GINGIVAL DESTRUCTION MAY HAVE BEEN DUE TO UNIONIZED AMMONIA LIBERATED FROM AMMONIUM SOLN.

Using a (51)Chromium release assay, the cytotoxic potencies of 56 test substances were evaluated in corneal endothelial cell cultures. All of these substances were nonirritants. Ammonium hydroxide was one of the tested substances.

Acids and alkalies /ammonium hydroxide/ were instilled into the eyes of 2 groups of rabbits; the eyes of 1 group were washed with tap water 30 seconds after exposure. All the alkalies of pH 11.5-13.5 produced opacities and other ocular damage of different degrees depending upon the alkali and its concn. Acidity and alkalinity of the test material are not the only factors to be considered in relation to a substances' capacity to produce severe ocular injury. The concn of the test chemical and its period of contact with the eye prior to washing are also important.

For more Non-Human Toxicity Excerpts (Complete) data for AMMONIUM HYDROXIDE (12 total), please visit the HSDB record page.

Agents causing ocular burns, steps in treatment, and special problems are described. Injuries are caused by neutral organic, acid, and alkali compounds. Contact time and pH are the most important variables in any chemical burn. The corneal epithelium and endothelium provide a barrier to water soluble substances while the stroma is a barrier to lipid soluble substances. Alkali compounds cause most severe injuries depending on the hydroxyl ion concentration and the cation. Calcium hydroxide, sodium hydroxide, and ammonium hydroxide are most often responsible for alkali burns. Ammonium hydroxide penetrates most rapidly of all alkali compounds.

Basic treatment: Establish a patent airway. Suction if necessary. Watch for signs of respiratory insufficiency and assist ventilations if necessary. Administer oxygen by nonrebreather mask at 6 to 12 L/min. Monitor for pulmonary edema and treat if necessary ... . Monitor for shock and treat if necessary ... . For eye contamination, flush eyes immediately with water. Irrigate each eye continuously with normal saline during transport ... . Do not use emetics. For ingestion, rinse mouth and administer 5 mL/kg up to 200 mL of water for dilution if the patent can swallow, has a strong gag reflex, and does not drool ... . Do not attempt to neutralize. Cover skin burns with dry sterile dressings after decontamination ... . /Inorganic bases/alkaline corrosives and related cmpds/

Advanced treatment: Consider orotracheal or nasotracheal intubation for airway control in the patient who is unconscious or in respiratory arrest. Early intubation, at the first signs of upper airway obstruction, may be necessary. Positive-pressure ventilation techniques with a bag-valve-mask device may be beneficial. Monitor cardiac rhythm and treat arrhythmias as necessary ... . Start an IV of D5W TKO /SRP: "To keep open", minimal flow rate/. Use lactated Ringer's if signs of hypovolemia are present. Watch for signs of pulmonary edema. For hypotension with signs of hypovolemia, administer fluid cautiously. Watch for signs of fluid overload ... . Consider drug therapy for pulmonary edema ... . Use proparacaine hydrochloride to assist eye irrigation ... . /Inorganic bases/alkaline corrosives and related cmpds/

Ammonium hydroxide used as a general purpose food additive in animal drugs, feeds, and related products is generally recognized as safe when used in accordance with good manufacturing or feeding practice.

Substance added directly to human food affirmed as generally recognized as safe (GRAS).

Residues of ammonium hydroxide are exempted from the requirement of a tolerance when used as a solvent, cosolvent, neutralizer, or solublizing agent in accordance with good agricultural practices as inert (or occasionally active) ingredients in pesticide formulations applied to growing crops or to raw agricultural commodities after harvest.

Persons in charge of vessels or facilities are required to notify the National Response Center (NRC) immediately, when there is a release of this designated hazardous substance, in an amount equal to or greater than its reportable quantity of 1000 lb or 454 kg. The toll free number of the NRC is (800) 424-8802; In the Washington D.C. metropolitan area (202) 426-2675. The rule for determining when notification is required is stated in 40 CFR 302.4 (section IV. D.3.b).