클로로포름산-2-클로로에틸에테르

(Non-Specific -- Ethyl Chloroformate) Keep unnecessary people away; isolate hazard area and deny entry. Stay upwind; keep out of low areas. Isolate for 1/2 mile in all directions if tank car or truck is involved in fire. Shut off ignition sources; no flares, smoking or flames in hazard area. Do not touch spilled material; stop leak if you can do so without risk. Use water spray to reduce vapors.

SRP: At the time of review, criteria for land treatment or burial (sanitary landfill) disposal practices are subject to significant revision. Prior to implementing land disposal of waste residue (including waste sludge), consult with environmental regulatory agencies for guidance on acceptable disposal practices.

SRP: The scientific literature for the use of contact lenses in industry is conflicting. The benefit or detrimental effects of wearing contact lenses depend not only upon the substance, but also on factors including the form of the substance, characteristics and duration of the exposure, the uses of other eye protection equipment, and the hygiene of the lenses. However, there may be individual substances whose irritating or corrosive properties are such that the wearing of contact lenses would be harmful to the eye. In those specific cases, contact lenses should not be worn. In any event, the usual eye protectionequipment should be worn even when contact lenses are in place.

1.8 [mg/m3]

20 [mg/m3]

120 [mg/m3]

For emergency situations, wear a positive pressure, pressure-demand, full facepiece self-contained breathing apparatus (SCBA) or pressure- demand supplied air respirator with escape SCBA and a fully-encapsulating, chemical resistant suit. (EPA, 1998)

TERRESTRIAL FATE: Chloroformates hydrolyze readily in water(1); therefore, aqueous hydrolysis will be the dominant fate process in moist soils(SRC). The low-boiling chloroformic esters, such as chloroethyl chloroformate, are highly volatile(2); therefore, evaporation from dry surfaces to the atmosphere will occur(SRC). Results of a single biodegradation study (using the Japanese MITI protocol) have classified ethyl chloroformate (a compound similar in structure to chloroethyl chloroformate) as biodegradable(3) but ethyl chloroformate hydrolyzes so fast the the biodegradation rates are probably for the hydrolysis products.

AQUATIC FATE: Chloroformates hydrolyze readily in water(1); ethyl chloroformate has an hydrolysis half-life of 31.5 min at 25 °C(1) and chloroethyl chloroformate is predicted to hydrolyze at a faster rate(2) forming the chloroethyl carbonate which can further hydrolyze to 2-chloroethanol and formic acid; therefore, aqueous hydrolysis will be the dominant fate process in the aquatic environment(SRC). Aqueous volatilization, bioconcentration, biodegradation, and adsorption to sediment are not expected to be important fate processes due to rapid hydrolysis(SRC).

ATMOSPHERIC FATE: Based upon a vapor pressure of 13 mm Hg at 48-49 °C(1), chloroethyl chloroformate is expected to exist primarily in the vapor-phase in the ambient atmosphere(2,SRC). It will degrade in the ambient atmosphere by reaction with photochemically produced hydroxyl radicals with an estimated half-life of about 14 days(3,SRC). Since chloroformates hydrolyzes readily in water(4), atmospheric degradation may occur through dissolution into clouds or through contact with rain or other atmospheric water(SRC).

Using a structure estimation method based on molecular connectivity indexes, the Koc for chloroethyl chloroformate can be estimated to be approximately 15(1,SRC). According to a suggested classification scheme(2), this estimated Koc value suggests that chloroethyl chloroformate has high mobility in soil(SRC). However, chloroformates hydrolyzes readily in water(3); therefore, leaching in soil is not expected to be an important fate process(SRC).

Using the Japanese MITI protocol (4 week incubation period with activated sludge inoculum), ethyl chloroformate (a compound similar in structure to chloroethyl chloroformate) was classified as biodegradable with a theoretical BOD of 81-86%(1) but this probably refers to the hydrolysis product(SRC).

The Henry's Law Constant for chloroethyl chloroformate can be estimated to be 1.1X10-3 atm-cu m/mole using a structure estimation method(1,SRC); this value of Henry's Law Constant indicates that volatilization from water is potentially an important fate process(2). However, chloroformates hydrolyze readily in water(3); therefore, volatilization from water is not expected to be important(SRC). The low- boiling chloroformic esters, such as chloroethyl chloroformate, are highly volatile(4); therefore, evaporation from dry surfaces will occur(SRC).

The rate constant for the vapor-phase reaction of chloroethyl chloroformate with photochemically produced hydroxyl radicals has been estimated to be 1.13X10-12 cu cm/molecule-sec at 25 °C which corresponds to an atmospheric half-life of about 14 days at an atmospheric concn of 5X10+5 hydroxyl radicals per cu cm(1,SRC). Chloroformates hydrolyze readily in pure water(2); although the hydrolysis rate specific to chloroethyl chloroformate was not found, the rate constant for the aqueous hydrolysis of ethyl chloroformate in water at 25 °C has been experimentally determined to be 3.67X10-4/sec which corresponds to a half life of 31.5 min(2); an hydrolysis rate estimation program(3) predicts that chloroethyl chloroformate will hydrolyze as much as three times faster than ethyl chloroformate(SRC).

... by ingestion and inhalation.

The low-boiling chloroformic esters (such as chloroethyl chloroformate) are highly volatile(1); therefore, occupational exposure can occur through inhalation(SRC).

Chloroethyl chloroformate's use as a chemical intermediate could release the compound to the environment through various waste streams generated at sites of production and use. If released to the atmosphere, it will degrade in the vapor phase by reaction with photochemically produced hydroxyl radicals (estimated half-life of about 14 days). Since chloroformates hydrolyze readily in water, atmospheric degradation may occur through dissolution into clouds or through contact with rain or other atmospheric water. If released to water or moist soil, hydrolysis will be the dominate degradation process. If released to dry surfaces, chloroethyl chloroformate will evaporate into the atmosphere. Occupational exposure is most likely to occur through inhalation. (SRC)

Releases of CERCLA hazardous substances are subject to the release reporting requirement of CERCLA section 103, codified at 40 CFR part 302, in addition to the requirements of 40 CFR part 355. Chloroethyl chloroformate is an extremely hazardous substance (EHS) subject to reporting requirements when stored in amounts in excess of its threshold planning quantity (TPQ) of 1,000 lbs.