Ferric Sulfate

HCID 24826

Grundinformationen

CAS
10028-22-5
Standard-SMILES
O=S(=O)([O-])[O-].O=S(=O)([O-])[O-].O=S(=O)([O-])[O-].[Fe+3].[Fe+3]
InChIKey
RUTXIHLAWFEWGM-UHFFFAOYSA-H
Summenformel
Fe2O12S3
Durchschnittliche Molmasse
399,9 g/mol
Monoisotopische Masse
399,72506

Namen und Bezeichner

Bevorzugter Name
Ferric Sulfate
IUPAC
bis(iron(3+));trisulfate
Englischer Name
Iron(III) sulfate
Summenformel
Fe2O12S3
Molmasse
399.8778

Namen und Synonyme

FERRIC SULFATEIron(III) sulfate10028-22-5Iron persulfateIron(3+) sulfateFerric persulfateIron sesquisulfateIron tersulfateDiiron trisulfateFerric tersulfateFerric sesquisulfateSulfuric acid, iron(3+) salt (3:2)
Weitere Namen anzeigen
Coquimbite mineralIron sulfate (2:3)Iron sulfate (Fe2(SO4)3)Iron(3+) sulfate, (2:3)4YKQ1X5E5YFERRIC SULFATE ANHYDROUSDTXSID5029712CHEBI:53438

Datenbank-Bezeichner

CAS
10028-22-5、142906-29-4
PubChem CID
24826
DTXSID
DTXSID5029712
ChEBI
CHEBI:53438
UNII
4YKQ1X5E5Y
EC Number
233-072-9、688-452-0

Eigenschaften

Berechnete Struktureigenschaften

Polarare Oberfläche (TPSA)
266 Ų
H-Brücken-Donoren
0
H-Brücken-Akzeptoren
12
Frei drehbare Bindungen
0
Schwere Atome
17

Experimentelle und physikochemische Eigenschaften

Density · 3 Einträge

3.1 at 68 °F (USCG, 1999) - Denser than water; will sink

3.097 at 18 °C

3.1 @25 °C

Color/Form · 2 Einträge

Grayish-white powder, or rhombic or rhombohedral crystals

Yellow crystals

Solubility · 3 Einträge

Soluble at room temperature

Slowly sol in water; rapidly sol in the presence of a trace of ferrous sulfate; sparingly sol in alc; practically insol in acetone, ethyl acetate.

Insol in sulfuric acid, ammonia

CorrosivityCorrosive to copper, copper alloys, mild steel, and galvanized steel.
Boiling PointThe Anhydrous form decomposes (480ºC)
DecompositionWhen heated to decomposition it emits toxic fumes /of iron and sulfur oxides./

Sicherheit und Regulatorisches

GHS-Klassifizierung

GHS Classification · 6 Einträge

This chemical does not meet GHS hazard criteria for 0.4% (2 of 446) of reports.

Danger

H290 (40.4%): May be corrosive to metals [Warning Corrosive to Metals];H302 (90.1%): Harmful if swallowed [Warning Acute toxicity, oral];H315 (87.7%): Causes skin irritation [Warning Skin corrosion/irritation];H317 (11.4%): May cause an allergic skin reaction [Warning Sensitization, Skin];H318 (80.7%): Causes serious eye damage [Danger Serious eye damage/eye irritation];H319 (18.8%): Causes serious eye irritation [Warning Serious eye damage/eye irritation];H335 (20.4%): May cause respiratory irritation [Warning Specific target organ toxicity, single exposure; Respiratory tract irritation]

P234, P261, P264, P264+P265, P270, P271, P272, P280, P301+P317, P302+P352, P304+P340, P305+P351+P338, P305+P354+P338, P317, P319, P321, P330, P332+P317, P333+P317, P337+P317, P362+P364, P390, P403+P233, P405, P406, and P501 (click each P-code to see the statement)

Aggregated GHS information provided per 446 reports by companies from 19 notifications to the ECHA C&L Inventory. Each notification may be associated with multiple companies.;Reported as not meeting GHS hazard criteria per 2 of 446 reports by companies.;There are 18 notifications provided by 444 of 446 reports by companies with hazard statement code(s).;Information may vary between notifications depending on impurities, additives, and other factors. The percentage value in parenthesis indicates the notified classification ratio from companies that provide hazard codes. Only hazard codes with percentage values above 10% are shown. For more detailed information, please visit ECHA C&L website.

Gefahrenhinweise

Regulatory Information · 6 Einträge

Chemical: Sulfuric acid, iron(3+) salt (3:2)

Hazard Traits - Respiratory Toxicity;Authoritative List - OEHHA RELs;Report - if used as a fragrance or flavor ingredient

Sulfuric acid, iron(3+) salt (3:2) is listed on the EPA's Chemical Data Reporting (CDR) system. Manufacturers and importers of Sulfuric acid, iron(3+) salt (3:2) are required to report information about their production and use of this chemical to the EPA under the Toxic Substances Control Act (TSCA). (40 eCFR Part 711)

Status: Active Update: 17-04-2020 https://echa.europa.eu/registration-dossier/-/registered-dossier/15372

Sulfuric acid, iron (III) salt: Does not have an individual approval but may be used under an appropriate group standard

The New Jersey Worker and Community Right to Know Act requires public and private employers to provide information about hazardous substances at their workplaces. (N.J.S.A. 34:5A-1 et. seq.)

Other Safety InformationIMAP assessments - Sulfuric acid, iron(3+) salt (3:2): Human health tier I assessment;IMAP assessments - Sulfuric acid, iron(3+) salt (3:2): Environment tier I assessment
Fire PotentialNot flammable
Health HazardsInhalation of dust irritates nose and throat. Ingestion causes irritation of mouth and stomach. Dust irritates eyes and can irritate skin on prolonged contact. (USCG, 1999)
Hazards SummaryA skin, eye, and mucous membrane irritant; Overexposure may cause liver damage; [Merck Index] A skin, eye, and throat irritant; [HSDB] An irritant; [MSDSonline] See Iron salts, soluble.
FDA Requirements · 2 Einträge

Substance added directly to human food affirmed as generally recognized as safe (GRAS).

Trace minerals added to animal feeds. These substances added to animal feeds as nutritional dietary supplements are generally recognized as safe when added at levels consistent with good feeding practice. All substances listed may be in anhydrous or hydrated form. Iron sulfate is included on this list. /Iron Sulfate/

Sicherheit und Schutzausrüstung

First AidINHALATION: move to fresh air.;INGESTION: give large amount of water; induce vomiting if large amounts have been swallowed.;EYES: flush with water; get medical attention if irritation persists.;SKIN: flush with water. (USCG, 1999)
Fire Fighting ProceduresIf material involved in fire: Extinguish fire using agent suitable for type of surrounding fire. (Material itself does not burn or burns with difficulty.)
Storage ConditionsKeep well closed and protected from light.
Cleanup Methods · 2 Einträge

Environmental considerations, land spill: Dig a pit, pond, lagon, holding area to contain liquid or solid material. /SRP: If time permits, pits, ponds, lagoons, soak holes, or holding areas should be sealed with an impermeable flexible membrane liner./ Dike surface flow using soil, sand bags, foamed polyurethane, or foamed concrete. Absorb bulk liquid with fly ash, cement powder, or commercial sorbents. Neutralize with agricultural lime, crushed limestone, or sodium bicarbonate.

Environmental considerations, water spill: Neutralize with agricultural lime, crushed limestone, or sodium bicarbonate. Adjust pH to neutral (pH= 7). Use mechanical dredges or lifts to remove immobilized masses of pollutants and precipitates.

Disposal Methods · 1 Eintrag

SRP: The most favorable course of action is to use an alternative chemical product with less inherent propensity for occupational exposure or environmental contamination. Recycle any unused portion of the material for its approved use or return it to the manufacturer or supplier. Ultimate disposal of the chemical must consider: the material's impact on air quality; potential migration in soil or water; effects on animal, aquatic, and plant life; and conformance with environmental and public health regulations.

Preventive Measures · 4 Einträge

SRP: The scientific literature for the use of contact lenses in industry is conflicting. The benefit or detrimental effects of wearing contact lenses depend not only upon the substance, but also on factors including the form of the substance, characteristics and duration of the exposure, the uses of other eye protection equipment, and the hygiene of the lenses. However, there may be individual substances whose irritating or corrosive properties are such that the wearing of contact lenses would be harmful to the eye. In those specific cases, contact lenses should not be worn. In any event, the usual eye protection equipment should be worn even when contact lenses are in place.

If material not involved in fire: Keep material out of water sources and sewers. Build dikes to contain flow as necessary.

Personnel protection: Keep upwind. ... Avoid breathing vapors or dusts. Wash away any material which may have contacted the body with copious amounts of water or soap and water.

All ... /iron/ preparations should be kept in child-proof bottles. /Iron preparations/

Toxikologische Informationen

Interactions · 1 Eintrag

...A brief exposure (1 hr) of 51Cr-radiolabeled breast cancer cells (BT-20) but not colon cancer cells (Caco-2) to hemin (10 uM) or FeSO4 (10 uM) significantly enhances cytotoxicity mediated by 0.5 mM hydrogen peroxide (H2O2). Associated with Caco-2 resistance, these cells were found to be enriched in the endogenous iron chelator, ferritin. If cellular ferritin is even further increased through 1 hr incubation (24 hr prior to H2O2 exposure) of both cell types with hemin, FeSO4, or exogenous spleen apoferritin itself (24 hr), marked resistance to H2O2-mediated cytotoxicity is manifest. Under several conditions, the sensitivity of tumor cells to oxidant-mediated lysis is inversely proportional to their ferritin content. Pretreatment of BT-20 and Caco-2 cells with hemin or FeSO4 rapidly increases H-ferritin mRNA but only slightly increases L-ferritin mRNA; nevertheless, large increases in overall ferritin content of iron-exposed cells result. Data analogous to those with H2O2-mediated cytotoxicity were obtained in studies of bleomycin-engendered DNA strand breakage and cell damage, i.e., brief treatment of BT-20 cells with both hemin or FeSO4 significantly increases their sensitivity to bleomycin (100 ug/mL), whereas treatment followed by 24 hr incubation with media alone significantly protects against bleomycin toxicity.

Ecotoxicity Values · 4 Einträge

LD50 Colinus virginianus (Northern bobwhite) oral via capsule >2250 mg/kg, 14 day exposure

LC50 Gambusia affinis (Western mosquitofish) 37.2 mg/L/24, 48, 96 hr; static

LC50 Salmo trutta (Brown trout) 28 mg total Fe/L (0.05 mg soluble Fe/L)/96 hr /Conditions of bioassay not specified in source examined/ /Commercial iron (III) sulphate liquor/

LC50 Salmo trutta (Brown trout) 47 mg total Fe/L (0.24 mg soluble Fe/L)/96 hr /Conditions of bioassay not specified in source examined/ /Analar grade iron (III) sulphate/

Adverse EffectsOccupational hepatotoxin - Secondary hepatotoxins: the potential for toxic effect in the occupational setting is based on cases of poisoning by human ingestion or animal experimentation.
Ecotoxicity Excerpts · 2 Einträge

/AQUATIC SPECIES/ The 96-hr LC50 on brown trout Salmo trutta of a commercial iron (III) sulphate liquor, used for treating reservoirs to reduce algal growth, was 28 mg total Fe/L (0.05 mg soluble Fe/L). The 96-hr LC50 for analar grade iron (III) sulphate was 47 mg total Fe/L (0.24 mg soluble Fe/L). Lethal and sublethal exposure to both grades of iron resulted in accumulation on the gill, which appears to be the main target for iron toxicity /in brown trout (Salmo trutta)/. Greater iron accumulation occurred during exposure to commercial iron sulfate liquor. Physical clogging of gills and gill damage was seen during lethal and sublethal exposure to iron. Gill tissue analysis showed no evidence of iron uptake into gill tissues during lethal or sublethal exposure to iron. Iron did not accumulate in plasma of fish exposed to iron compared to controls. Respiratory disruption due to physical clogging of the gills is suggested as a possible mechanism for iron toxicity.

/AQUATIC SPECIES/ ...The acute and chronic effects upon Daphnia longispina, the dominant member of the zooplankton. Laboratory tests established that, although dissolved iron had no measurable effect, the presence of particulate iron caused mortalities in acute tests (48 hours) and reduced number of broods per female and numbers of young hatching in chronic tests (21 days). At 11.48 mg Fe/L, 50% mortalities occurred in the population, /while/ 4.49 mg Fe/L caused reductions in reproduction and increased mortality rates over 21 day tests. In inert china clay, similar results were observed, suggesting that it was the particulate nature of the ferric sulfate that caused the effects, rather than any toxic properties. A safe level of 1.69 mg Fe/L was calculated. The area of the filter of the third thoracic limb of the daphnids, from both the laboratory cultures and the south arm of Rutland Water (which received ferric-dosed inlet water) increased in size in the presence of ferric sulfate and china clay in chronic tests. This is a response to low food concentrations. Abnormal feeding behavior was also observed in ferric sulfate. Thoracic beat rate, decreased in ferric sulfate but was unaffected in china clay. This suggested that the feeding rate depression was a response to the chemical nature of the ferric sulfate, rather than its particulate nature. The number of times that particles were rejected from the food groove increased in both ferric sulfate and china clay, in response to large clumps of these substances collecting there.

Human Toxicity Excerpts · 1 Eintrag

/HUMAN EXPOSURE STUDIES/ Twenty normal and 18 asthmatic human volunteers were exposed to ferric sulfate aerosol at a nominal concentration of 75 ug/cu m (equivalent to 20 ug iron/cu m). The concentration and particle size distribution (2 micron mass median aerodynamic diameter; geometric standard deviation of 3) were selected to simulate worst case ambient conditions. Ferric sulfate was chosen for study because it is toxic, it is a respiratory system irritant, and increased use of coal and high sulfur fuel oils will lead to increased concentrations of iron and sulfate in ambient air. A double blind protocol was followed in which each subject was exposed on two days, separated by about a three week period. The subjects were exposed to clean air (sham) on one day and to ferric sulfate aerosol on the other (exposure); the order of exposure was selected randomly. Neither the subjects nor the staff performing the clinical testing were informed as to the nature of the atmosphere on any given day. Pulmonary function tests were performed immediately before (pre) and after (post) each 2 hr sham or exposure period; this protocol included intermittent exercise. Pre and postexposure symptom score interviews were also administered. On the average, the two groups of subjects did not exhibit significant pre to postchanges in total respiratory system resistance, forced expiratory flow/volume performance, and single breath nitrogen washout parameters. None of the subjects reported more than slight changes in symptoms during exposure. Five individuals showed small but significant decremental trends in pulmonary function; however, nine subjects tended to improve after exposure.

Non-Human Toxicity Excerpts · 3 Einträge

/LABORATORY ANIMALS: Acute Exposure/ .../iron-sulfate/ or vehicle (dimethylsulfoxide or aqueous ethanol) alone was applied to the dorsum of each ear of female BALB/c-mice for 3 consecutive days; in some animals, the dorsal surface of the ear was gently abraded by needle just prior to metal salt application. Mice were sacrificed 4 days after the initial application for preparation and analysis of /lymph node cells/ (LNCs). Results were expressed as the stimulation indices value resulting in an increase of lymphocyte proliferation in draining lymph nodes relative to vehicle treated groups. While nickel, cobalt, chromium, and copper salts increased LNC proliferation, zinc, manganese, and iron salts did not. LNC proliferation tended to increase with increased concentration of metal salt.

/LABORATORY ANIMALS: Subchronic or Prechronic Exposure/ A study was performed to provide data on the disposition, accumulation and toxicity of sodium iron EDTA in comparison with iron (II) sulfate in rats on administration via the diet for 31 and 61 days. ...Iron is accumulated from the diet in liver, spleen and kidneys in a dose-dependent manner, and iron derived from FeEDTA is taken up and/or accumulated less efficiently in liver and spleen than iron from FeSO(4). Moreover, feeding iron up to 11.5 and 11.2 mg/kg bw/day, derived from FeSO(4) and FeEDTA, respectively, did not result in tissue iron excess nor in any other toxicologically significant effects.

/LABORATORY ANIMALS: Subchronic or Prechronic Exposure/ ...Standardized osseous defects were created bilaterally in the naturally edentulous zone in rabbit mandibles. The control site was sutured immediately after clot formation in the defect. The contralateral experimental site received ferric sulfate application until complete hemostasis was achieved. The defect was filled with ferric sulfate solution to maximize any effect on healing and then closed with sutures. The experimental and control specimens were examined histologically after 18 and 46 days and scored for healing. Statistical analysis by Wilcoxon signed rank test showed significant adverse effects on osseous healing when ferric sulfate solution was left in situ.

Regulatorische Informationen

Regulatory Information · 6 Einträge

Chemical: Sulfuric acid, iron(3+) salt (3:2)

Hazard Traits - Respiratory Toxicity;Authoritative List - OEHHA RELs;Report - if used as a fragrance or flavor ingredient

Sulfuric acid, iron(3+) salt (3:2) is listed on the EPA's Chemical Data Reporting (CDR) system. Manufacturers and importers of Sulfuric acid, iron(3+) salt (3:2) are required to report information about their production and use of this chemical to the EPA under the Toxic Substances Control Act (TSCA). (40 eCFR Part 711)

Status: Active Update: 17-04-2020 https://echa.europa.eu/registration-dossier/-/registered-dossier/15372

Sulfuric acid, iron (III) salt: Does not have an individual approval but may be used under an appropriate group standard

The New Jersey Worker and Community Right to Know Act requires public and private employers to provide information about hazardous substances at their workplaces. (N.J.S.A. 34:5A-1 et. seq.)

FDA Requirements · 2 Einträge

Substance added directly to human food affirmed as generally recognized as safe (GRAS).

Trace minerals added to animal feeds. These substances added to animal feeds as nutritional dietary supplements are generally recognized as safe when added at levels consistent with good feeding practice. All substances listed may be in anhydrous or hydrated form. Iron sulfate is included on this list. /Iron Sulfate/

FIFRA Requirements · 1 Eintrag

Residues of ferric sulfate are exempted from the requirement of a tolerance when used as a solid diluent or carrier in accordance with good agricultural practices as inert (or occasionally active) ingredients in pesticide formulations applied to growing crops or to raw agricultural commodities after harvest.

CERCLA Reportable Quantities · 1 Eintrag

Persons in charge of vessels or facilities are required to notify the National Response Center (NRC) immediately, when there is a release of this designated hazardous substance, in an amount equal to or greater than its reportable quantity of 1000 lb or 454 kg. The toll free number of the NRC is (800) 424-8802; In the Washington D.C. metropolitan area (202) 426-2675. The rule for determining when notification is required is stated in 40 CFR 302.4 (section IV. D.3.b).

Clean Water Act Requirements · 1 Eintrag

Ferric sulfate is designated as a hazardous substance under section 311(b)(2)(A) of the Federal Water Pollution Control Act and further regulated by the Clean Water Act Amendments of 1977 and 1978. These regulations apply to discharges of this substance. This designation includes any isomers and hydrates, as well as any solutions and mixtures containing this substance.

Federal Drinking Water GuidelinesEPA 300 ug/L /Iron/

Chemie und Industrie

Pharmakologische Informationen

Protein BindingFerric sulfate presents very high protein binding properties, this property is thought to be due to its acidic profile.
PharmacodynamicsThe administration of ferric sulfate as a dermatologic agent has showed delayed reepithelialization and dyspigmentation. Some studies have reported the generation of inflammation in the sites of administration of ferric sulfate.
Mechanism of Action · 1 Eintrag

The main function of ferric sulfate is as a hemostatic agent in different medical practices. This hemostatic function is achieved when ferric sulfate is applied directly in the damaged tissue. Once applied, ferric sulfate forms ferric ion-protein complex which helps the sealing of the damaged vessels mechanically. The formation of agglutinated protein complexes produces the generation of occlusion in the capillary orifices. The formation of the ferric protein complex is thought to be due to a chemical reaction between the acidic form of ferric sulfate and the blood proteins.

Biological Half-LifePharmacokinetic studies related to the half-life of ferric sulfate have not been performed.
Metabolism/MetabolitesPharmacokinetic studies related to the metabolism of ferric sulfate have not been performed.
FDA Pharmacological Classification · 2 Einträge

FERRIC SULFATE

Phosphate Binder [EPC]; Iron [CS]; Parenteral Iron Replacement [EPC]; Phosphate Chelating Activity [MoA]

Verwendung und Herstellung

Uses · 6 Einträge

Used to make iron salts and pigments, as a coagulant in water purification and sewage treatment, in etching aluminum, in pickling stainless steel and copper, as a mordant in textile dyeing and calico printing, in soil conditioners, as a polymerization catalyst, in the coal conversion process (desulfurization), in the ferric salt leaching process, as a disinfectant, and as a hemostatic agent for endodontic surgery; [HSDB]

Aluminum Producing [Category: Industry];Steel Producing [Category: Industry];Metal Preparation and Pouring [Category: Foundry];Using Disinfectants or Biocides [Category: Clean];Farming (Pesticides) [Category: Industry];Sewer and Wastewater Treatment [Category: Industry];Textiles (Printing, Dyeing, or Finishing) [Category: Industry]

For ferric sulfate (USEPA/OPP Pesticide Code: 034902) ACTIVE products with label matches. /SRP: Registered for use in the U.S. but approved pesticide uses may change periodically and so federal, state and local authorities must be consulted for currently approved uses./

The primary use for ferric sulfate is in water and wastewater treatment.

In preparation of iron alums, other iron salts and pigments; as coagulant in water purification and sewage treatment; in etching aluminum; in pickling stainless steel and copper; as mordant in textile dyeing and calico printing; in soil conditioners; as polymerization catalyst.

Fertilizer /Iron(III) sulfate, enneahydrate/

U.S. Production2023: 250,000,000 - <400,000,000 lb;2022: 400,000,000 - <550,000,000 lb;2021: 250,000,000 - <400,000,000 lb;2020: 250,000,000 - <400,000,000 lb
Consumption PatternsThe primary use for ferric sulfate is in water and wastewater treatment.
Consumer UsesNot Known or Reasonably Ascertainable;Flocculating agent
Industry Uses · 1 Eintrag

Plating agent;Deodorizer;Processing aids not otherwise specified;Soil amendments (fertilizers);Not Known or Reasonably Ascertainable;Cleaning agent;Softener and conditioner;Etching agent;Adhesion/cohesion promoter;Chelating agent;Flocculating agent;Solids separation (precipitating) agent, not otherwise specified;Intermediate

Methods of Manufacturing · 2 Einträge

... Prepared by treating iron(II) sulfate with boiling concentrated sulfuric acid, or by evaporating a mixture of iron(III) oxide and sulfuric acid. Iron(III) sulfate solutions are produced industrially by injecting chlorine gas into an iron(II) sulfate solution. The solution thus obtained contains a mixture of iron(III) sulfate and iron(III) chloride.

By adding sulfuric acid to ferric hydroxide.

Anbieter100 Anbieter

湖北永阔科技有限公司027-59223108 15972152991 · [email protected]
湖北万得化工有限公司15377098680 15377098680 · [email protected]
南通润丰石油化工有限公司66017690 19952660367 · [email protected]
上海康朗生物科技有限公司021-61998208 18217752821 · [email protected]
湖北宥澄新材料科技有限公司17764017698 13163370568 · [email protected]

Zugehörige Reaktionen

6

Notizen zur Verbindung

Wird geladen…