Potassium Chlorate

Excerpt from ERG Guide 140 [Oxidizers]:

Excerpt from ERG Guide 140 [Oxidizers]:

In case of fire in the surroundings, use appropriate extinguishing media. In case of fire: keep drums, etc., cool by spraying with water. Combat fire from a sheltered position.

Fresh air, rest. Refer for medical attention.

First rinse with plenty of water for at least 15 minutes, then remove contaminated clothes and rinse again. Refer for medical attention .

First rinse with plenty of water for several minutes (remove contact lenses if easily possible), then refer for medical attention.

Rinse mouth. Refer immediately for medical attention.

· CALL 911. Then call emergency response telephone number on shipping paper. If shipping paper not available or no answer, refer to appropriate telephone number listed on the inside back cover.

· Keep combustibles (wood, paper, oil, etc.) away from spilled material.

· CALL 911. Then call emergency response telephone number on shipping paper. If shipping paper not available or no answer, refer to appropriate telephone number listed on the inside back cover.

· Keep combustibles (wood, paper, oil, etc.) away from spilled material.

EYES: flush with water for at least 15 min.

Excerpt from ERG Guide 140 [Oxidizers]:

General First Aid:

General First Aid:

· Wear positive pressure self-contained breathing apparatus (SCBA).

· Wear positive pressure self-contained breathing apparatus (SCBA).

Not combustible, but substance is a strong oxidizer and its heat of reaction with reducing agents or combustibles may cause ignition. When heated, it releases oxygen which increases combustion. Use any means suitable for extinguishing surrounding fire. Water spray may be used to keep fire exposed containers cool. In the event of a fire, wear full protective clothing and NIOSH-approved self-contained breathing apparatus with full facepiece operated in the pressure demand or other positive pressure mode.

If material on fire or involved in fire: Flood with water. Cool all affected containers with flooding quantities of water. Apply water from as far a distance as possible. /Potassium chlorate; Potassium chlorate, aqueous solution/

Evacuation: If fire becomes uncontrollable-consider evacuation of one-half (1/2) mile radius. /Potassium chlorate; Potassium chlorate, aqueous solution/

... Containers of potassium chlorate should be protected from physical damage and sudden shocks.

Keep in a tightly closed container, stored in a cool, dry, ventilated area. Protect against physical damage and moisture. Isolate from any source of heat or ignition. Avoid storage on wood floors. Separate from incompatibles, combustibles, organic or other readily oxidizable materials. Containers of this material may be hazardous when empty since they retain product residues (dust, solids); observe all warnings and precautions listed for the product.

Accidental Release Measures. Remove all sources of ignition. Ventilate area of leak or spill. Wear appropriate personal protective equipment as specified in Section 8. Spills: Clean up spills in a manner that does not disperse dust into the air. Use non-sparking tools and equipment. Reduce airborne dust and prevent scattering by moistening with water. Pick up spill for recovery or disposal and place in a closed container.

Excerpt from ERG Guide 140 [Oxidizers]:

Excerpt from ERG Guide 140 [Oxidizers]:

SRP: The most favorable course of action is to use an alternative chemical product with less inherent propensity for occupational exposure or environmental contamination. Recycle any unused portion of the material for its approved use or return it to the manufacturer or supplier. Ultimate disposal of the chemical must consider: the material's impact on air quality; potential migration in soil or water; effects on animal, aquatic, and plant life; and conformance with environmental and public health regulations.

Whatever cannot be saved for recovery or recycling should be handled as hazardous waste and sent to a RCRA approved waste facility. Processing, use or contamination of this product may change the waste management options. State and local disposal regulations may differ from federal disposal regulations. Dispose of container and unused contents in accordance with federal, state and local requirements.

Sodium chlorate (NaClO3) and potassium chlorate (KClO3) ... were tested for potential promoting effect in two-stage rat renal carcinogenesis. Three groups of 15 male F344 rats each were given N-ethyl-N-hydroxyethylnitrosamine (EHEN) at the level of 0.05% for the first 2 weeks during the initiation phase. Thereafter, the rats were treated orally for 25 weeks with NaClO3 (1%), KClO3 (1%), or distilled water (DW). Three other groups (controls) were treated similarly, except that DW was given in the initiation phase. All animals survived for the duration of the experiment. Renal neoplastic lesions were classified histologically as dysplastic foci (DF) and renal cell tumors (RCT). The number of these lesions per unit area, in six sections from each kidney, was determined microscopically. There were no statistically significant differences in the incidences and in the mean number of DF and RCT of the kidney between compound- and DW-treated rats initiated with EHEN. It is concluded that NaClO3 and KClO3 show no promoting effect in rat renal carcinogenesis under the conditions of this study.

Sodium chlorate (NaClO3) and potassium chlorate (KClO3) ... were tested for potential promoting effect in two-stage rat renal carcinogenesis. Three groups of 15 male F344 rats each were given N-ethyl-N-hydroxyethylnitrosamine (EHEN) at the level of 0.05% for the first 2 weeks during the initiation phase. Thereafter, the rats were treated orally for 25 weeks with NaClO3 (1%), KClO3 (1%), or distilled water (DW). Three other groups (controls) were treated similarly, except that DW was given in the initiation phase. All animals survived for the duration of the experiment. Renal neoplastic lesions were classified histologically as dysplastic foci (DF) and renal cell tumors (RCT). The number of these lesions per unit area, in six sections from each kidney, was determined microscopically. There were no statistically significant differences in the incidences and in the mean number of DF and RCT of the kidney between compound- and DW-treated rats initiated with EHEN. It is concluded that NaClO3 and KClO3 show no promoting effect in rat renal carcinogenesis under the conditions of this study.

EC50; Species: Chlorococcales (Green algae); Conditions: freshwater, static; Concentration: 210 mg/L for 24 hr; Effect: physiology, assimilation efficiency /formulated product/

LC50; Species: Daphnia magna (Water flea, age < or =24 hr); Conditions: freshwater, static, 20-22 °C, pH 7.6-7.7; Concentration: 880 mg/L for 24 hr

LC50 Eisenia foetida and Lombricus lombricus (Earthworm) >750 mg/kg soil dry weight for 14 days; artificial soil (test substrate consisted of 83.5% fine quartz sand, 5 bentonite, 10% finely ground dried sphagnum peat, 1% calcium carbonate, and 0.5% cattle manure)

The safety of this ingredient has not been documented and substantiated. The CIR Expert Panel cannot conclude whether Potassium Chlorate is safe for use in cosmetic products until the appropriate safety data have been obtained and evaluated.

Ingredients for which the data are insufficient and their use in cosmetics is not supported

Cough. Sore throat.

Redness.

Redness. Pain.

Abdominal pain. Blue lips, fingernails and skin. Confusion. Convulsions. Diarrhoea. Dizziness. Headache. Nausea. Shortness of breath. Sore throat. Unconsciousness. Vomiting. Symptoms may be delayed.

/SIGNS AND SYMPTOMS/ Inhalation: Causes irritation to the respiratory tract. Symptoms may include coughing, shortness of breath. Ingestion: Causes irritation to the gastrointestinal tract. Symptoms may include nausea, vomiting and diarrhea. May cause abdominal pain, hemolysis, methemoglobinemia, cyanosis, anuria, coma, and convulsions. May cause liver and kidney damage. Death may occur from renal failure, generally in 4 days. Estimated lethal dose from 15 to 30 grams. Skin Contact: Causes irritation to skin. Symptoms include redness, itching, and pain. Eye Contact: Causes irritation, redness, and pain.

/SIGNS AND SYMPTOMS/ From.../cases of accidental or suicidal ingestion/, the lethal dose in adults is estimated to be... 5 to 30 g for potassium chlorate.

/SIGNS AND SYMPTOMS/ Ingestion of more than a few grams of sodium or potassium chlorate results in acute intravascular hemolysis and anuric renal failure. Before 1960 the renal complication of chlorate poisoning was almost invariably fatal though since then successful treatment of the renal failure by peritoneal dialysis or hemodialysis has been recorded on a number of occasions

/SIGNS AND SYMPTOMS/ There are clinical descriptions of poisoning from accidental or suicidal ingestion of...overdose of potassium chlorate... Common poisonous effects are the rapid oxidative destruction of red blood cells, possibly followed or preceded by increased methemoglobin, and eventual cyanosis and progressive kidney failure.

For more Human Toxicity Excerpts (Complete) data for POTASSIUM CHLORATE (13 total), please visit the HSDB record page.

/LABORATORY ANIMALS: Acute Exposure/ Potassium chlorate is a relatively powerful inhibitor of catalase ... . The inhibition is irreversible.

/LABORATORY ANIMALS: Acute Exposure/ ... The oral lowest lethal dose (LDLO) of potassium chlorate was 7,000 mg/kg for rats, 2,000 mg/kg for rabbits ... and 1,200 mg/kg for dogs ... . The average oral lethal dose, that is, the dose that would produce acute poisoning and death within 1 hr, of potassium chlorate in an M/1 solution was 7.0 and 7.5 g/kg for 29 albino rats and 32 guinea pigs, respectively ... The ip LDLO of potassium chlorate for rats was 1,500 mg/kg ... . The average ip lethal dose of potassium chlorate in an M/2 solution was 1.5 and 1.8 g/kg for 29 albino rats and 32 guinea pits, respectively ... .

/LABORATORY ANIMALS: Acute Exposure/ ... Potassium chlorate has produced renal tubular necrosis in animals ... . /Oral acute toxicity/

/LABORATORY ANIMALS: Subchronic or Prechronic Exposure/ ...Seven cats /were given/ IM injections of potassium...chlorate in 5% or 10% solution. Daily doses of 0.05 to 0.25 g/kg were administered for 25 to 32 days. None of...cats had demonstrable methemoglobin. But, upon histological exam, all cats receiving greater than 0.05 g/kg showed fibrosis and atrophy of distal renal tubules.

For more Non-Human Toxicity Excerpts (Complete) data for POTASSIUM CHLORATE (7 total), please visit the HSDB record page.

Immediate first aid: Ensure that adequate decontamination has been carried out. If patient is not breathing, start artificial respiration, preferably with a demand-valve resuscitator, bag-valve-mask device, or pocket mask, as trained. Perform CPR as necessary. Immediately flush contaminated eyes with gently flowing water. Do not induce vomiting. If vomiting occurs, lean patient forward or place on left side (head-down position, if possible) to maintain an open airway and prevent aspiration. Keep patient quiet and maintain normal body temperature. Obtain medical attention. /Chlorates and Related Compounds/

Basic treatment: Establish a patent airway (oropharyngeal or nasopharyngeal airway, if needed). Suction if necessary. Watch for signs of respiratory insufficiency and assist ventilations if necessary. Administer oxygen by nonrebreather mask at 10 to 15 L/min. Anticipate seizures and treat if necessary ... . For eye contamination, flush eyes immediately with water. Irrigate each eye continuously with 0.9% saline (NS) during transport ... . Do not use emetics. For ingestion, rinse mouth and administer 5 ml/kg up to 200 ml of water for dilution if the patient can swallow, has a strong gag reflex, and does not drool ... . /Chlorates and Related Compounds/

Advanced treatment: Consider orotracheal or nasotracheal intubation for airway control in the patient who is unconscious or is in severe respiratory distress. Start IV administration of D5W /SRP: "To keep open", minimal flow rate/. Use 0.9% saline (NS) or lactated Ringer's (LR) if signs of hypovolemia are present. For hypotension with signs of hypovolemia, administer fluid cautiously. Watch for signs of fluid overload ... . Treat seizures with diazepam or lorazepam ... . Use proparacaine hydrochloride to assist eye irrigation ... . /Chlorates and Related Compounds/

Emergency and supportive treatment: Maintain on open airway and assist ventilation if necessary. Treat coma, hemolysis, hyperkalemia, and renal or hepatic failure if they occur. Massive hemolysis may require blood transfusions. To prevent renal failure resulting from deposition of free hemoglobin in the kidney tubules, administer intravenous fluids and sodium bicarbonate. /Chlorates/

Specific drugs and antidotes: Treat methemoglobinemia with methylene blue, ... . Methylene blue is reportedly most effective when used early in mild cases but has poor effectiveness in severe cases in which hemolysis has already occurred. Intravenous sodium thiosulfate may inactivate the chlorate ion and has been reported to be successful in anecdotal reports. However, this treatment has not been clinically tested. Administration as a lavage fluid may potentially produce some hydrogen sulfide, and so it is contraindicated. /Chlorates/

LD50 Rat oral 1870 mg/kg bw

LD50 Mouse oral 8350 mg/kg bw

LD50 Rabbit oral 7200 mg/kg bw

Potassium chlorate

A Commercial Grade

400

Explosive/Improvised Explosive Device Precursor material that, if stolen or diverted, can be converted into weapons using simple chemistry, equipment, or techniques.

(CA) CALIFORNIA 800 ug/L /Chlorate ion/

(ME) MAINE 7 ug/L /Chlorate ion/

CIR ingredient: Potassium Chlorate

Used in the production of explosives, fireworks, matches, and dyes; used in textile dyeing; Dilute solutions have been used as antiseptics and mouthwash (vet); [Merck Index] Used in pulp and paper manufacturing; [HSDB] Used in photography (platinum printing); [www.ci.tucson.az.us/arthazards/medium.html]

Pulp and Paper Processing [Category: Industry]

Intalagio printing [Category: Hobbies]

Oxidizing agent, explosives, matches, source of oxygen, textile printing, pyrotechnics, percussion caps, disinfectant, bleaching.

Explosives; fireworks; matches; printing and dyeing cotton and wool black; manuf aniline black and other dyes; source of oxygen; in chemical analyses.

(1972) No Data

(1975) No Data

(1972) 2.05X10+8 GRAMS

(1975) 2.02X10+8 GRAMS

(1) By electrolyzing a hot concentrated alkaline solution of potassium chloride. Preferably (2) by interaction of solutions of potassium chloride and sodium chlorate or calcium chlorate.

Potassium chlorate is generally made from potassium chloride and sodium chlorate. ... Solid KCl is added to the sodium chlorate cell liquor in stoichiometric amounts. The mixture is then transferred to a crystallizer and the potassium chlorate slurry is removed ... The mother liquor is recycled to the cells, where the salt is converted to chlorate and the process is repeated. Quality requirements for solid KCl are high, because no purification is possible after it is added to the solution.

Food Additives -> BLEACHING_AGENT; FLOUR_TREATMENT_AGENT -> JECFA Functional Classes

Cosmetics -> Oxidising

Chloric acid, potassium salt (1:1): ACTIVE

"STRIKE-ANYWHERE" OR KITCHEN MATCH...IS MADE OF...24% POTASSIUM CHLORATE... "SAFETY" OR STRIKE-ON-BOX MATCH...IN HEAD, CHIEF INGREDIENT IS POTASSIUM CHLORATE.

Incompatible with iodides, tartaric acid. ... explodes with sulfuric acid; inflames with explosion if titrated with any organic substances, sulfur, phosphorus, sulfite, hyposulfite, and other oxidizable substances.