과망간산칼륨

Excerpt from ERG Guide 140 [Oxidizers]:

In case of fire in the surroundings, use appropriate extinguishing media.

Fresh air. Half-upright position. Artificial respiration may be needed. Refer immediately for medical attention.

Wear protective gloves when administering first aid. First rinse with plenty of water for at least 15 minutes, then remove contaminated clothes and rinse again. Refer for medical attention .

Rinse with plenty of water for several minutes (remove contact lenses if easily possible). Refer immediately for medical attention.

Rinse mouth. If within a few minutes after ingestion, one small glass of water may be given to drink. Do NOT induce vomiting. Refer immediately for medical attention.

· CALL 911. Then call emergency response telephone number on shipping paper. If shipping paper not available or no answer, refer to appropriate telephone number listed on the inside back cover.

· Keep combustibles (wood, paper, oil, etc.) away from spilled material.

INGESTION: induce vomiting and follow with thorough gastric lavage, demulcents, glucose I.V., fluid therapy, and antibiotics. Tracheostomy may be lifesaving. (USCG, 1999)

General First Aid:

The material itself is noncombustible but it will accelerate the burning of combustible material. If the combustible material is finely divided the mixture may be explosive. Contact with liquid combustible materials may result in spontaneous ignition.

· Wear positive pressure self-contained breathing apparatus (SCBA).

TIH (Toxic Inhalation Hazard) - Term used to describe gases and volatile liquids that are toxic when inhaled. Some are TIH materials themselves, e.g., chlorine, and some release TIH gases when spilled in water, e.g., chlorosilanes. [ERG 2016].

0.2 [mg/m3], as MN (inhalable fraction), 0.02 mg/m3, as Mn (respirable fraction)[German Research Foundation (DFG)]

If material on fire or involved in fire: Flood with water. Cool all affected containers with flooding quantities of water. Apply water from as far a distance as possible.

Evacuation: If fire becomes uncontrollable - consider evacuation of one-half (1/2) mile radius.

Environmental considerations: Land spill: Dig a pit, pond, lagoon, holding area to contain liquid or solid material. /SRP: If time permits, pits, ponds, lagoons, soak holes, or holding areas should be sealed with an impermeable flexible membrane liner./ Cover solids with a plastic sheet to prevent dissolving in rain or fire fighting water. Add sodium bisulfite (NaHSO3).

Environmental considerations: Water spill: Add dilute caustic soda (NaOH). Add sodium bisulfite (NaHSO3). Use mechanical dredges or lifts to remove immobilized masses of pollutants and precipitates.

SRP: At the time of review, criteria for land treatment or burial (sanitary landfill) disposal practices are subject to significant revision. Prior to implementing land disposal of waste residue (including waste sludge), consult with environmental regulatory agencies for guidance on acceptable disposal practices.

Personal protection: chemical protection suit including self-contained breathing apparatus. Do NOT let this chemical enter the environment. Sweep spilled substance into covered containers. Carefully collect remainder. Then store and dispose of according to local regulations. Do NOT absorb in saw-dust or other combustible absorbents.

EYES: irrigate opened eyes for several minutes under running water. INGESTION: do not induce vomiting. Rinse mouth with water (never give anything by mouth to an unconscious person). Seek immediate medical advice. SKIN: should be treated immediately by rinsing the affected parts in cold running water for at least 15 minutes, followed by thorough washing with soap and water. If necessary, the person should shower and change contaminated clothing and shoes, and then must seek medical attention. INHALATION: supply fresh air. If required provide artificial respiration.

IN STUDIES OF RETINOTOXIC EFFECTS OF FLUORIDE IN ANIMALS, POTASSIUM PERMANGANATE HAS BEEN UTILIZED SYSTEMICALLY AS OXIDIZING AGENT TO ENHANCE TOXICITY.

4-Deoxypyridoxine (4-DPD) is a potent antagonist of Vitamin B6 coenzyme which inhibits IL-1, lymphocyte proliferation & has demonstrated that tolerance to skin grafts can be induced by administering splenic cells to pyridoxine-deficient mice. Chronic inflammation induced by dorsal injections of 200 microliters of a 1:40 saturated crystal soln of potassium permanganate (KMnO4) in mice treated or untreated with 4-DPD (400 micrograms/dose), has been investigated. After 7 days all mice developed a subcutaneous granulomatous tissue indicative of a chronic inflammatory response, at the site of injection. KMnO4-treated mice injected ip with 4-DPD (400 micrograms/dose) on 5 consecutive days (the first at the same time of induction of the granuloma) show a significant decr in size & weight of granuloma when compared to mice not treated with 4-DPD (Controls). In addition, in all mice treated with 4-DPD there was a strong inhibition of TNF alpha in serum (P < 0.01) & in supernatant fluids (P < 0.05) from minced granuloma, while IL-6 was inhibited in the supernatant fluids (P < 0.05) of minced granulomas but was not detected in the serum of treated & untreated mice. In this study we show for the first time the antiinflammatory effect of 4-DPD on chronic inflammation & the inhibitory effect of TNF & IL-6 generation in supernatant fluids from minced granulomas.

Manganese mainly affects the nervous system and may cause behavioral changes and other nervous system effects, which include movements that may become slow and clumsy. This combination of symptoms when sufficiently severe is referred to as “manganism”. (L228)

LC50 CARASSIUS AURATUS (GOLDFISH) 3.6 MG/L/96 HR /CONDITIONS OF BIOASSAY NOT SPECIFIED/

LC50 ICTALURUS PUNCTATUS (CHANNEL CATFISH) 0.75 MG/L/96 HR /CONDITIONS OF BIOASSAY NOT SPECIFIED/

LD50 Lepomis macrochirus (bluegill sunfish) 2.7-3.6 mg/l /Conditions of bioassay not specified/

Serious local effects by all routes of exposure.

Oral (L228) ; inhalation (L228)

Manganese is a cellular toxicant that can impair transport systems, enzyme activities, and receptor functions. It primarily targets the central nervous system, particularily the globus pallidus of the basal ganglia. It is believed that the manganese ion, Mn(II), enhances the autoxidation or turnover of various intracellular catecholamines, leading to increased production of free radicals, reactive oxygen species, and other cytotoxic metabolites, along with a depletion of cellular antioxidant defense mechanisms, leading to oxidative damage and selective destruction of dopaminergic neurons. In addition to dopamine, manganese is thought to perturbations other neurotransmitters, such as GABA and glutamate. In order to produce oxidative damage, manganese must first overwhelm the antioxidant enzyme manganese superoxide dismutase. The neurotoxicity of Mn(II) has also been linked to its ability to substitute for Ca(II) under physiological conditions. It can enter mitochondria via the calcium uniporter and inhibit mitochondrial oxidative phosphorylation. It may also inhibit the efflux of Ca(II), which can result in a loss of mitochondrial membrane integrity. Mn(II) has been shown to inhibit mitochondrial aconitase activity to a significant level, altering amino acid metabolism and cellular iron homeostasis. (L228)

Burning sensation. Cough. Sore throat. Shortness of breath. Laboured breathing. Symptoms may be delayed.

Redness. Skin burns. Pain.

Redness. Pain. Severe burns.

Burning sensation. Abdominal pain. Diarrhoea. Nausea. Vomiting. Shock or collapse.

Manganese mainly affects the nervous system and may cause behavioral changes and other nervous system effects, which include movements that may become slow and clumsy. This combination of symptoms when sufficiently severe is referred to as “manganism”. (L228)

A. ACUTE POISONING: 1. INGESTION OF SOLID OR CONCN POTASSIUM PERMANGANATE CAUSES BROWN DISCOLORATION & EDEMA OF MUCOUS MEMBRANES OF MOUTH & PHARYNX; COUGH, LARYNGEAL EDEMA, & STRIDOR; NECROSIS OF ORAL & PHARYNGEAL MUCOSA; SLOW PULSE; & SHOCK WITH FALL OF BLOOD PRESSURE. IF DEATH IS NOT IMMEDIATE, JAUNDICE & OLIGURIA OR ANURIA MAY APPEAR. 2. APPLICATION OF SOLID OR CONCN POTASSIUM PERMANGANATE SOLN TO MUCOUS MEMBRANES OF VAGINA OR URETHRA CAUSES SEVERE BURNING, HEMORRHAGES, & VASCULAR COLLAPSE. PERFORATION OF VAGINAL WALL MAY OCCUR, RESULTING IN PERITONITIS WITH FEVER & ABDOMINAL PAIN. EXAM REVEALS CHEMICAL BURNS WHICH ARE STAINED BROWN.

A CASE OF PYLORIC STENOSIS FOLLOWING INGESTION OF POTASSIUM PERMANGANATE WAS DESCRIBED. THIS IS A RARE CAUSE OF PYLORIC STENOSIS.

GASTRIC LESIONS WERE CAUSED BY INGESTION OF POTASSIUM PERMANGANATE IN ADULT FEMALE.

TWO PATIENTS INGESTED POWDER CONSISTING OF MIXT OF SOOT & POTASSIUM PERMANGANATE. BOTH WERE COMATOSE & EXPERIENCED DEEP CYANOSIS BUT RESPONDED WELL TO OXYGEN, METHYLENE BLUE, & VIT C.

For more Human Toxicity Excerpts (Complete) data for POTASSIUM PERMANGANATE (16 total), please visit the HSDB record page.

MUTAGENICITY: MUTATION RESEARCH 87: 211 (1981). DNA REPAIR DEFICIENT BACTERIAL TESTS: NEGATIVE.

EXPERIMENTALLY IN RABBITS, IRRIGATION OF CORNEA WITH 0.003 MOLAR SOLN POTASSIUM PERMANGANATE HAS BEEN FOUND TO CAUSE NO INJURY, BUT INJECTION OF 0.08 MOLAR SOLN INTO CORNEA CAUSED MODERATELY SEVERE REACTION, GRADED 60 ON SCALE OF 0 TO 100.

... STRONG SOLN AND CRYSTALS OF POTASSIUM PERMANGANATE IN CONTACT WITH EYE HAVE CAUSED SEVERE DAMAGE. ... IN AREA OF CONTACT A ... LESION HAS DEVELOPED, COLORED DARK BROWN BY MANGANESE OXIDE FORMED ... SWELLING OF LIDS & CONJUNCTIVAE, AND ... SUBCONJUNCTIVAL HEMORRHAGES. WITH PROLONGED CONTACT TURBIDITY & ... DISCOLORATION OF CORNEA ... RECOVERY USUALLY /IS/ ... SPONTANEOUS ... BUT IN ONE INSTANCE TOTAL LEUKOMA /DENSE WHITE OPACITY OF CORNEA/ IS REPORTED FOLLOWING APPLICATION OF STRONG SOLN OF POTASSIUM PERMANGANATE.

POTASSIUM PERMANGANATE INJECTED SC IN HIGH DOSES INTO MALE MICE CAUSED DAMAGE & CALCIFICATION OF PANNICULUS CARNOSUS MUSCLE.

For more Non-Human Toxicity Excerpts (Complete) data for POTASSIUM PERMANGANATE (10 total), please visit the HSDB record page.

Potassium permanganate is an indirect food additive for use only as a component of adhesives.

Food starch may be bleached by treatment with one or more of the following: ... potassium permanganate, not to exceed 0.2 percent. Limitations: Residual manganese (calculated as Mn), not to exceed 50 ppm in food starch-modified.

Listed as a hazardous air pollutant (HAP) generally known or suspected to cause serious health problems. The Clean Air Act, as amended in 1990, directs EPA to set standards requiring major sources to sharply reduce routine emissions of toxic pollutants. EPA is required to establish and phase in specific performance based standards for all air emission sources that emit one or more of the listed pollutants. Potassium permanganate is included on this list.

... Substances for which a Federal Register notice has been published that included consideration of the serious health effects, including cancer, form ambient air exposure to the substance. Manganese (50 FR 32627; Aug. 13, 1985) is included on this list. /Manganese/

Persons in charge of vessels or facilities are required to notify the National Response Center (NRC) immediately, when there is a release of this designated hazardous substance, in an amount equal to or greater than its reportable quantity of 100 lb or 45.4 kg. The toll free number of the NRC is (800) 424-8802; In the Washington D.C. metropolitan area (202) 426-2675. The rule for determining when notification is required is stated in 40 CFR 302.4 (section IV. D.3.b).

Potassium permanganate is designated as a hazardous substance under section 311(b)(2)(A) of the Federal Water Pollution Control Act and further regulated by the Clean Water Act Amendments of 1977 and 1978. These regulations apply to discharges of this substance. This designation includes any isomers and hydrates, as well as any solutions and mixtures containing this substance.

Potassium permanganate

A Commercial Grade

400

Explosive/Improvised Explosive Device Precursor material that, if stolen or diverted, can be converted into weapons using simple chemistry, equipment, or techniques.

Used to bleach textile fibers and skins, to dye wood and fabrics, to etch rubber and plastics, and to descale steel; Used in food processing, photography, leather tanning, and water purification; Used as an antiseptic, disinfectant, insecticide, miticide, and algaecide; [HSDB]

Using Disinfectants or Biocides [Category: Clean]

For Potassium permanganate (USEPA/OPP Pesticide Code: 068501) ACTIVE products with label matches. /SRP: Registered for use in the U.S. but approved pesticide uses may change periodically and so federal, state and local authorities must be consulted for currently approved uses./

Used occasionally for bulbs and rhizomes, and for dipping grafting knives and other tools.

Bleaching resins, waxes, fats, oils, straw, cotton, silk and other fibers and chamois skins; dyeing wood brown; printing fabrics; washing carbon dioxide in manuf mineral waters; exterminating Oidium tuckeri; photography; tanning leathers; purifying water; with formaldehyde soln to expel formaldehyde gas for disinfecting; as an important reagent in analytical and synthetic organic chemistry.

THERAP CAT: Anti-infective (topical)

2023: 10,000,000 - <50,000,000 lb

14,000 tons/year

May be prepared by oxidizing manganese dioxide with potassium chlorate in potassium hydroxide soln, then completing the oxidation with chlorine or air & carbon dioxide.

(1) By oxidation of the manganate in an alkaline electrolytic cell. (2) A hot solution of the mangenate is treated with carbon dioxide; on cooling, the solution deposits crystals fo the permanganate.

May be manufactured by one-step electrolytic conversion of ferromanganese to permanganate, or by a two-step process involving the thermal oxidation of manganese oxide of a naturally occurring ore into potassium manganate followed by electrolytic oxidation to permanganate...

Roasting processes that employ manganese(IV) oxide:potassium hydroxide molar ratio of 1:2 to 1:3 (reaction mixture is a solid); heated to 300-400 °C; exposed to secondary oxidation at 190-210 °C.

Liquid-phase process with a manganese(IV) oxide:potassium hydroxide molar ratio greater than or equal to 1:5; molten mixture at 200-350 °C is oxygenated; separation of product.

Grades: technical, CP (chemically pure), USP

Formulations include ready to use liquids (0.004%-2.5%), pelleted/tableted (40%), crystals (80%-99.99%), and powder (41%).

ICC 237 Disinfectant, Sanitizer, Destainer, and Deodorizer; soluble concn, 0.01% potassium permanganate.

Chlorisol; soluble concn, 0.01% potassium permanganate.

For more Formulations/Preparations (Complete) data for POTASSIUM PERMANGANATE (10 total), please visit the HSDB record page.

Potassium permanganate

A chemical, other than a List I chemical, specified by regulation that, in addition to legitimate uses, is used in manufacturing a controlled substance in violation of the Act. (21 eCFR 1310.02)

Agriculture, Forestry, Fishing and Hunting

Permanganic acid (HMnO4), potassium salt (1:1): ACTIVE